Changes in Thermal Kinetics Characteristics during Low-Temperature

Dec 1, 2016 - ACS Journals. ACS eBooks; C&EN Global Enterprise ..... 3.2DSC-TG under Lean-Oxygen Conditions and Analysis. Figures 3–5 show the ...
0 downloads 0 Views 2MB Size
Subscriber access provided by Macquarie University

Article

Changes in thermal kinetics characteristics during low-temperature oxidation of low-ranking coals under lean-oxygen conditions Xiaoxing Zhong, Linda Li, Yun Chen, Guolan Dou, and Haihui Xin Energy Fuels, Just Accepted Manuscript • DOI: 10.1021/acs.energyfuels.6b02197 • Publication Date (Web): 01 Dec 2016 Downloaded from http://pubs.acs.org on December 2, 2016

Just Accepted “Just Accepted” manuscripts have been peer-reviewed and accepted for publication. They are posted online prior to technical editing, formatting for publication and author proofing. The American Chemical Society provides “Just Accepted” as a free service to the research community to expedite the dissemination of scientific material as soon as possible after acceptance. “Just Accepted” manuscripts appear in full in PDF format accompanied by an HTML abstract. “Just Accepted” manuscripts have been fully peer reviewed, but should not be considered the official version of record. They are accessible to all readers and citable by the Digital Object Identifier (DOI®). “Just Accepted” is an optional service offered to authors. Therefore, the “Just Accepted” Web site may not include all articles that will be published in the journal. After a manuscript is technically edited and formatted, it will be removed from the “Just Accepted” Web site and published as an ASAP article. Note that technical editing may introduce minor changes to the manuscript text and/or graphics which could affect content, and all legal disclaimers and ethical guidelines that apply to the journal pertain. ACS cannot be held responsible for errors or consequences arising from the use of information contained in these “Just Accepted” manuscripts.

Energy & Fuels is published by the American Chemical Society. 1155 Sixteenth Street N.W., Washington, DC 20036 Published by American Chemical Society. Copyright © American Chemical Society. However, no copyright claim is made to original U.S. Government works, or works produced by employees of any Commonwealth realm Crown government in the course of their duties.

Page 1 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

1

Changes in thermal kinetics characteristics during

2

low-temperature oxidation of low-ranking coals under

3

lean-oxygen conditions Xiaoxing Zhong*,†,‡, Linda Li†,‡, Yun Chen§, Guolan Dou†,‡, Haihui Xin†,‡

4 5



6

Technology, Xuzhou 221116, China

7



School of Safety Engineering, China University of Mining and Technology, Xuzhou 221116, China

8

§

FAW-Volkswagen Automobile Co. Ltd, Changchun 130000, China

9

ABSTRACT: The present work derives the heat flow and mass-loss curves for the oxidation of

10

three low-ranking coals under lean-oxygen conditions using thermogravimetry and differential

11

scanning calorimetry. Relationships between the exothermic character of the low-temperature

12

oxidation (the stage before the volatile combustion of coal) and oxygen concentration were

13

analyzed. Kinetic parameters for low-temperature coal oxidation under lean-oxygen conditions

14

were obtained, based on a derived Arrhenius equation. The results demonstrate that there is a

15

critical oxygen concentration, above which the full oxidative combustion reaction of low-ranking

16

coal will reach under lean-oxygen conditions of continuous ventilation; if the oxygen

17

concentration exceeds the critical value, the temperature at which coal oxidative combustion

18

reaction is completed is retarded as the oxygen concentration decreases. The amount of heat

19

released during low-temperature oxidation decreases with the decrease of oxygen concentration,

20

but the influence on total quantity of heat released is small. During the low-temperature oxidation

21

of low-ranking coal, three stages of kinetic parameters were defined: during Stages 1 and 2, the

22

apparent activation energy and pre-exponential factor fluctuated slightly at average values as the

Key Laboratory of Coal Methane and Fire Control, Ministry of Education, China University of Mining and

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

23

oxygen concentration changed; however, during Stage 3, the apparent activation energy decreased

24

in a linear manner as the oxygen concentration decreased and pre-exponential factor for XJ-H and

25

XJ-Z coal samples decreased in a linear manner while it decreased in an exponential manner for

26

PS coal sample.

27

Keywords: Low-ranking coal; Oxygen-poor; Low-temperature oxidation; Kinetic parameters

28

1. INTRODUCTION

29

With respect to the interaction of coal and oxygen, spontaneous combustion may occur when

30

the rate of heat generation from the coal is faster than its rate of release. Spontaneous combustion

31

not only wastes coal resources, but produces hazardous gases and can cause gas or coal dust

32

explosions.1-2 An understanding of the thermal and kinetic parameters of the low-temperature coal

33

oxidation process is necessary to forecast and avoid the risks of spontaneous combustion in coal

34

mine goafs and coal fire areas.

35

Adiabatic oxidation, basket heating, and thermal analysis are generally applicable methods for

36

studying coal oxidation at low temperatures. Some scholars have studied the process based on the

37

adiabatic oxidation technique proposed by Davis and Byrne3 in 1924. Adiabatic oxidation was

38

adopted by Ren et al.4 to study the tendency for spontaneous combustion in 18 coal samples and

39

the influences of moisture content, grain diameter, initial temperature, and sample pre-oxidation

40

on the process. Beamish et al.5 used adiabatic oxidation experiments to determine the heating rate

41

and analyze how this influences pre-oxidation. From measuring adiabatic temperature curves for

42

nine coal samples, Lin et al.6 concluded that the activation energy gradually decreased with

43

increasing temperature during the spontaneous combustion process. Adiabatic measurements are,

44

however, very time-consuming because the experimental conditions are harsh and the amount of

ACS Paragon Plus Environment

Page 2 of 34

Page 3 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

45

heat generated during the initial oxidation step is small. The traditional basket-heating method is

46

based on Frank-Kamenetskii’s steady-state analysis, but this method requires the critical

47

temperatures of many different-sized coal samples. Chen7 and Jones et al.8 later proposed a revised

48

basket-heating method, which only needs to test the junction temperature of a single-sized coal in

49

the critical temperature range. Although the testing time is less than that of the Frank-Kamenetskii

50

method, it is necessary to change temperatures to confirm the critical temperature, so this

51

approach is still time-consuming. Compared with adiabatic oxidation and basket-heating methods,

52

thermal analysis has the advantages of requiring fewer test samples, a shorter experimental

53

duration, and good repeatability and is now widely used in the study of spontaneous combustion

54

of coal.9-17 Qingsong Wang11-12 adopted C80 microcalorimeter to test the exothermic process of

55

coal spontaneous combustion and predicted the self-heating oxidation temperatures (SHOT) of

56

coal stockpile. Peng Chen13 adopted TG-DSC to test thermal decomposition process at different

57

heating rate for three different ranks coal, and a model-fitting method and an isoconversional

58

method are adopted to analyze the kinetic parameter at low-temperature oxidation stage. Rotaru14

59

adopted thermogravimetry (TG), differential scanning calorimetry (DSC), and differential thermal

60

analysis (DTA) to examine the exothermic processes of Romanian and Urals oblast bituminous

61

coals and compared their kinetic parameters. Benfell et al.15 used thermogravimetry to analyze

62

New Zealand and Eastern Australian coals, and identified the temperatures of the various features

63

of the exothermic process and the relationship between the volatile matter content of different

64

grain diameters and the maximum rate of combustion. Zhang et al.16 tested Shengdong coal and

65

determined the TG curves for the low-temperature oxidation step using the difference between

66

experiments carried out in dry air and in pure nitrogen. Changdong Sheng, Li et al.17 used TGA

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

67

and DSC to analyze the dynamic parameters of low-temperature oxidation of coal and compared

68

these with results obtained from the basket heating method.

69

Most experimental research into the low-temperature oxidation of coal has, however, been

70

conducted in an air atmosphere. In actual coal mine production, spontaneous combustion disasters

71

happen under lean-oxygen conditions, when the oxygen concentration is lower than that of air. For

72

instance, spontaneous combustion of goaf occurs in the self-sustaining combustion zone, where

73

the oxygen concentration is between 5% and 18%.18-21 Spontaneous combustion in coalfield fire

74

areas also creates lean-oxygen conditions because consumption of oxygen during the burning of

75

the fire lowers the oxygen concentration of those areas with poor ventilation to below that of air.

76

Research into the thermal properties of the low-temperature oxidation of coal under

77

lean-oxygen conditions is rare, and most is concerned with determining thermodynamic properties

78

at a particular low oxygen concentration. Wang et al.22 derived kinetic data from one model coal

79

and three real coal samples under conditions of 10% oxygen, based on DTG experiments. Zhan et

80

al.23 analyzed the exothermic character and activation energy of coal in 10% oxygen. Changdong

81

Sheng, Li et al.17 compared the kinetic data obtained at 5% and 15% oxygen concentrations using

82

TGA–DSC. There is currently no systematic study concerning the effect of oxygen concentration

83

on the thermal properties of low-temperature oxidation of coal under lean-oxygen conditions.

84

Spontaneous combustion occurs particularly in low metamorphic coals (low-ranking coal)

85

such as lignite, long flame coal and non-caking coal and so on.24-25 This type of low-ranking coal

86

comprises about half of the world’s coal reserves. About 41% of global low-ranking coal reserves

87

occur in China, mainly distributed in Xin Jiang municipality, Shanxi and Shanxi Province.26 This

88

study measures the heat flow and mass changes during the reaction of low-ranking coal under

ACS Paragon Plus Environment

Page 4 of 34

Page 5 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

89

lean-oxygen conditions, based on TG–DSC methods, and analyzes changes in kinetics

90

characteristics of the low-temperature oxidation.

91

2. EXPERIMENTAL SECTION

92

2.1. Coal samples. Low-ranking coal samples were sourced from the coal area of Hoxtolgay,

93

Xinjiang Province (long flame coal labeled XJ-H), the south opencast coal mine of Zhundong,

94

Xinjing Province (non-caking coal XJ-Z), and the No. 3 coal mine of the China National Coal

95

Group Co., Ltd., in Pingshuo, Shanxi Province (long flame coal PS). Since spontaneous

96

combustion all happened to untreated raw coal in coal mine goafs, coal fire areas and ground coal

97

piles, raw coal collected from the coal mine was selected as coal sample in this experiment. The

98

fresh raw coal lumps were taken from the coal mine and sent to the laboratory hermetically and

99

preserved in the low temperature. In the experiment, coal sample lumps were milled with their

100

surfaces stripping under an inert atmosphere in a glove box and fragments which met the particle

101

sizes required were used for the experimental investigations. Where, in order to analyze the

102

influence of particle size to heat flow values, the experimental particle sizes of XJ-Z coal were set

103

as 200-450µm, 125-200µm, 96-125µm, 74-96µm and <74µm respectively, from which the

104

optimal particle size applicable to this experiment will be selected. The experimental particle size

105

of XJ-H coal and PS coal was the optimal particle size of XJ-Z coal selected. Their properties are

106

given in Table 1.

107

2.2. Experimental process. Simultaneous thermal analysis was carried out in a SDT-Q600

108

instrument (TA of American), which was used to conduct TG and DSC experiments on XJ-Z coal

109

first. At the oxygen concentration of 21%, the change of heat flow for XJ-Z coal of five different

110

particle sizes with the reaction temperature, so as to analyze the optimal particle size applicable to

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

111

this experiment. Then, at the optimal particle sizes, the change of the heat flow and mass of the

112

three low-ranking coals with the reaction temperature under different oxygen concentrations.

113

Reaction gases in this experiment is composed of ultra-high-purity N2 and ultra-high-purity O2 at

114

certain proportion, with the oxygen concentration being 21%, 16%, 12%, 8%, 6%, 4%, and 2%

115

respectively. The purge gas flow rate was 100 ml/min and the sample was heated from 28°C to

116

1000°C at a heating rate of 2°C/min.27

117

3. RESULTS AND DISCUSSION

118

3.1. DSC of XJ-Z coal at different particle sizes and analysis. Figure 1 shows the heat flow

119

curves of XJ-Z coal of different particle sizes at the oxygen concentration of 21%. The stagnation

120

temperature (Tc) of the coal in the low-temperature step is determined by extrapolation of the

121

onset of the heat flow curve.28 As shown in Figure 2, To is the initial exothermic temperature and

122

the range from To to Tc represents the low-temperature oxidation step. The To values for XJ-Z coal

123

sample at different particle sizes are shown in Table 2. For XJ-Z coal sample at different particle

124

sizes, the heat outputs of the entire exothermic process, ∆H, and the heat released by

125

low-temperature oxidation, ∆HL, were obtained by integrating the heat flow curves; the results are

126

given in Table 2. From Figure 1 and Table 2, it can be seen that when the particle decreased, the

127

initial exothermic temperature decreased while the heat released by low-temperature oxidation

128

increased and showed stronger exothermic effect. Because the reaction of coal was relatively weak

129

in low-temperature oxidation and the mass of testing coal used in the TG-DSC experimental

130

system was only 10mg, if coal samples with large particles were chosen as testing coal, the heat

131

flow value would be greatly influenced by the response accuracy of SDT-Q600 instrument. On the

132

contrary, effect of SDT-Q600 instrument’s response accuracy on test data was reduced by

ACS Paragon Plus Environment

Page 6 of 34

Page 7 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

133

choosing coal samples with small particles and test data would be more accurate. It will also help

134

to analyze the reaction characteristics of coal at low temperature oxidation. Therefore, coal sample

135

with particle size < 74 microns was selected as testing sample at different oxygen concentrations.

136

3.2. DSC-TG under lean-oxygen conditions and analysis. Figures 3 to 5 show the heat flow

137

(DSC) and TG curves for the coal samples in an oxygen-poor atmosphere. From the heat flow

138

curve, it can be seen that for three coal samples there is a distinct difference between curves when

139

the oxygen concentration is 2% and curves with other oxygen concentration. The heat flow curve

140

resembles that of a pyrolysis process under pure N2 conditions, where the oxidative combustion

141

reaction cannot continue. For the PS sample, although there is a combustion peak for the

142

high-temperature step at an oxygen concentration of 4%, there is a visible decrease in heat flow

143

for oxygen concentrations of 6% to 21% and the curve remains in the low-temperature phase.

144

From Figure 5(b), we can see a distinction between the TG curves at 4% oxygen for the PS sample

145

and those above this value. The TG characteristics below 450 °C are similar to those measured at

146

an oxygen concentration of 2%. This illustrates that the oxidative combustion reaction cannot

147

continue for these samples when the oxygen concentration is 4%. For oxygen concentrations

148

above 4% for XJ-H and XJ-Z and above 6% for PS, the overall trends of the heat flow curves for

149

the various oxygen concentrations are similar. As the temperature increases, the heat flow

150

increases gradually at first and two exothermic peaks appear during combustion; the first one is

151

volatiles exothermic peak and the second one is fixed carbon exothermic peak. The first

152

exothermic peak for three coal samples is lower than the second one. With lower oxygen

153

concentration, the exothermic peak decreases and the exothermic process migrates to the

154

high-temperature step. This illustrates that the reaction rate slows down when the oxygen

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

155

concentration is low and higher temperature is needed for complete reaction.

156

The overall trends of the TG curves resemble each other under lean-oxygen conditions. As the

157

oxygen concentration is reduced, the TG curves shift to higher temperature. Until oxygen

158

concentrations is 2% for XJ-H and XJ-Z and is 4% for PS, the TG curves show obvious migration.

159

To analyze how the oxygen concentration influences the initial and final reaction rates, differential

160

processing was applied. Figure 6(a) shows the DTG curves of XJ-H, as an example. The oxygen

161

concentration has a similar influence on the initial and final reaction rates. Figure 6(b) shows a

162

partially enlarged portion of the low-temperature DTG curve (where a negative DTG value

163

signifies mass gain). As the oxygen concentration decreases, the maximum rate of mass gain

164

decreases and the mass-gain temperature range shrinks. The mass-gain process disappears when

165

the oxygen concentration is equal to or lower than 4%. This may be explained as follows: mass

166

variation in the low-temperature oxidative process is caused by oxygen absorption during surface

167

oxidation of the coal and the formation of intermediate products (ethers, carbonyls, and other

168

stable materials belonging to the carbonyl class); when the oxygen concentration is too low, the

169

oxidation rate and oxygen absorption slows down and the mass loss caused by the decomposition

170

of the intermediate products becomes larger than the mass gain attributed to oxygen absorption, so

171

the overall performance is a loss of mass. When the temperature rises to about 230°C, the coal

172

samples rapidly lose mass; the lower the oxygen concentration, the lower the rate of mass loss.

173

3.3. Relationship between thermal characteristics of the low-temperature oxidation phase

174

and oxygen concentration. The To and Tc values for the three coal samples under different

175

oxygen concentrations, as well as the heat outputs of the entire exothermic process, ∆H, and the

176

heat released by low-temperature oxidation, ∆HL, are shown in Table 3. From Table 3, it is seen

ACS Paragon Plus Environment

Page 8 of 34

Page 9 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

177

that when the oxygen concentration exceeds 4% for XJ-H and XJ-Z and 6% for PS, the total heat

178

released during the entire exothermic process changes little and the initial exothermic temperature

179

is generally the same with the variation of oxygen concentration in the poorly ventilated

180

atmosphere. When the oxygen concentration is 2% for XJ-H and XJ-Z and 4% for PS, the

181

exothermic character of three coal samples in low-temperature oxidation has not been detected.

182

Although there is an exothermic peak in the later reaction of PS coal sample at an oxygen

183

concentration of 4%, the decreasing range for heat outputs of the entire exothermic process is

184

greater than that of at oxygen concentration exceeding 6%. This indicates that a critical oxygen

185

concentration exists for different coals (the critical oxygen concentration is between 2% and 4%

186

for XJ-H and XJ-Z and between 4% and 6% for PS), at which the oxidation combustion reaction is

187

full under oxygen-poor conditions. The coal can still fully react when the oxygen concentration

188

exceeds this critical value; however, the temperature required for the complete reaction is retarded,

189

although both To and Tc hardly vary as the oxygen concentration is reduced. The heat output for

190

the entire reaction and the ratio of this to the total heat released during the low-temperature

191

oxidation decrease as the oxygen concentration decreases. This explains why the extent of

192

oxidation in the low-temperature step decreased with decreasing oxygen concentration.

193

4. CHANGE OF KINETIC PARAMETERS DURING LOW-TEMPERATURE

194

OXIDATION OF COAL UNDER OXYGEN-LEAN CONDITIONS

195

4.1. Principle of determination of kinetic parameters. Kinetic analysis can be carried out using

196

either the single or multiple scan-rate methods.29-31 In the process of solving kinetic parameters

197

using a single scan rate, it is necessary to first select a linear optimal equation as the most probable

198

mechanism function using the “mode matching method”; however, because of the dynamic

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Page 10 of 34

199

compensation effect, when kinetic triplets are determined from a thermal analysis curve, the

200

values of the apparent activation energy (E) and the pre-exponential factor (A) can provide a good

201

linear fit for all mode functions by mutual compensation. Therefore, unless either E or the most

202

probable mechanism function f(α) are ascertained beforehand, the accuracy of kinetic results

203

obtained from a single curve is greatly affected. Multiple scan-rate methods, such as those of

204

Flynn–Wall–Ozawa (FWO), Kissinger–Akahira–Sunose (KAS), and Friedman, conduct kinetic

205

analysis by measuring the exothermic peak at different temperature rise rates; however, because of

206

the high temperature of the exothermic peak for coal samples, the results obtained generally reflect

207

the characteristics of the coal combustion step, rather than the low-temperature oxidation step.

208

In view of the defects of these traditional methods, Changdong Sheng, Li et al.17 and

209

Changdong Sheng, Fan et al.32 proposed a method based on TG–DSC experiments to study the

210

low-temperature oxidation of coal. According to the kinetic theory of chemical reactions and the

211

Arrhenius Law, the rate of heat release (the reaction order is assumed to be 1) is given by:

212

 = exp − ⁄ 

(1)

213

Where q is the rate of heat release (W); m is the mass of the coal sample (g); Q is the heat of

214

reaction (J/g); A is the pre-exponential factor (s−1); is the apparent activation energy (J/mol);

215

R is the universal gas constant (8.314 J/(mol·K)); and T is the reaction temperature (K). When a

216

calorimeter is used to conduct kinetic analysis of the oxidation of coal, eq 1 is usually used to

217

represent the rate of heat release for the exothermic low-temperature oxidation process.

218 219 220

Processing eq 1 by transposition and taking logarithms gives: ln  ⁄ = ln  − ⁄ 

(2)

Where q and m at any temperature are obtained from the TG and DSC experimental conditions.

ACS Paragon Plus Environment

Page 11 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

221

A scatter diagram of ln(q/m) against 1/T is plotted and linear fitting is performed; E and A are

222

respectively determined from the slope and intercept.

223

4.2. Relationship between kinetic parameters and oxygen concentration for the

224

low-temperature oxidation step. Using eq 2, scatter diagrams of ln(q/m) against 1000/T for the

225

low-temperature oxidation of coal were plotted by analyzing the TG–DSC experimental results for

226

XJ-H and XJ-Z at oxygen concentrations between 4% and 21% and for PS at oxygen

227

concentrations between 6% and 21%. Considering sample XJ-H with an oxygen concentration of

228

21% as an example (Figure 7), ln(q/m) shows three stages of kinetic behavior as the temperature

229

increases: first an increase (defined as Stage 1), then a slow increase (Stage 2), and finally a rapid

230

increase (Stage 3). The scatter values exhibit good linear correlation with 1000/T. The equations of

231

the linear fits to each of the three stages are shown in Figure 7. (To avoid the influence of

232

transitions between stages, some points in the transition regions were discarded in the linear fitting

233

process.)17 The intersection point of fitting curves are treated as the demarcation point of three

234

stages.

235

The values of E and A for the three stages of low-temperature oxidation of three coal samples

236

were calculated from the respective slopes and intercepts; the results are shown in Table 4. For

237

these three coal samples, the apparent activation energy of the process is small, especially in Stage

238

2, the value of which is significantly smaller than that for Stages 1 and 3. The apparent activation

239

energy under certain oxygen concentrations is even negative. The reason is that the

240

low-temperature reaction of coal is very complicated which includes moisture evaporation,

241

physical and chemical absorption of oxygen accompanied by change of heat flow and mass. The

242

value of apparent activation energy at different stage is depended on the relation of q/m and

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

243

temperature (T) at different stages. When the ln(q/m) is of negative temperature coefficient, the

244

apparent activation energy is negative.16,33-35 The values of A throughout the low-temperature

245

oxidation step were relatively small, which is consistent with the slow reaction rates.

246

Figures. 8 to 10 show the variation of the kinetic parameters of coal samples XJ-H, XJ-Z, and

247

PS, respectively, with oxygen concentration. The influence of oxygen concentration on the kinetic

248

parameters in Stages 1 and 2 is small: the apparent activation energies (E) of samples XJ-H, XJ-Z,

249

and PS in Stage 1 fluctuate slightly around 5.26 kJ/mol, 22.13 kJ/mol, and 3.02 kJ/mol,

250

respectively, while A averages 3.41×10−4 s−1, 0.033 s−1, and 1×10−4 s−1, respectively; for Stage 2, E

251

for samples XJ-H, XJ-Z, and PS averages 0.392 kJ/mol, −0.29 kJ/mol, and −0.182 kJ/mol,

252

respectively, and A averages 6.34×10−5 s−1, 3.68×10−5 s−1, and 2.72×10−5 s−1, respectively.

253

However, the kinetic parameters of Stage 3 differ significantly, the Origin, a data processing

254

software was used in the fitting of the changing relationship between the kinetic parameters and

255

oxygen concentration at the Stage 3 of low-temperature oxidation. The function which could

256

obtain the maximal value of goodness of fit R2 would be the final function of relationship between

257

the kinetic parameters and oxygen concentration in Stage 3. The result shows that E decreases

258

linearly with decreasing oxygen concentration. The relationships between the apparent activation

259

energy and oxygen concentration ( ) for XJ-H, XJ-Z, and PS in Stage 3 are given by =

260

0.44 + 7.01, E = 0.62c" + 4.65, and E = 0.85c" + 5.56, respectively. The pre-exponential

261

factor decreases either linearly or exponentially: the relationships between A and oxygen

262

concentration for XJ-H and XJ-Z during Stage 3 are given by  = 1.97 × 10'(  − 4.6 × 10'(

263

and  = 1.04 × 10'(  − 1.18 × 10'(, respectively, while that of PS is A = 0.002e*.++(,- .

264

4.3. Application and comparison. The above analyses illustrate that, for continuous ventilation

ACS Paragon Plus Environment

Page 12 of 34

Page 13 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

265

under lean-oxygen conditions and in the oxygen concentration range required for full oxidative

266

combustion, a rule—not a constant value—determines the change in apparent activation energy

267

and pre-exponential factor of the low-temperature oxidation of coal as the oxygen concentration

268

decreases. In calculation using Arrhenius equation, we must therefore revise the expressions for E

269

and A of the reaction rate constant, k, as given in eq 3; other research into spontaneous combustion

270

processes occurring in coal piles, gob mining, and other areas36 proposes the use of eq 4. eq 5 is an

271

equation for calculating k transformed from eq 1.

272

k =  g co2  exp(−  f co2  / RT )    

( )

(3)

273

k =  c( o2 )  A′ exp( − E ′ / RT )

(4)

274

k=

( ) n

q

(5)

mQ

275

Where k is the reaction rate constant (s-1);  refers to the oxygen concentration (%);

276

./ 0is the function that prescribes how the apparent activation energy changes with oxygen

277

concentration; g ( co ) is the function that prescribes how the pre-exponential factor changes with 2

278

oxygen concentration; n is the reaction order (generally 1)36; E ′ refers to the apparent activation

279

energy at Stage 3 when the oxygen concentration is at 21%. Where, A′ =A/0.21 (A is the

280

pre-exponential factor obtained in this paper at the third stage of low temperature oxidation at the

281

oxygen concentration of 21%).

282

Considering the low-temperature oxidation of XJ-H coal in 12% oxygen as an example, Figure

283

11 shows the k value calculated from eqs 3 and 4 compared with the experimental results

284

calculated from eq 5. The k value obtained in eq 3 closely approximates that in experimental

285

measurements, while that in eq 4 differs significantly from these.

286

Table 5 shows the extent of deviation between the calculated and experimental k values for

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

287

XJ-H coal at oxygen concentrations of 12%, 8%, and 6% and temperatures of 50°C, 100°C, 150°C,

288

and 200°C. Table 5 indicates that, regardless of the relationship between E and A and the oxygen

289

concentration, the extent of deviation between the calculated and experimental k values at different

290

temperatures reduces as the oxygen concentration increases. According to this comparison,

291

revision of the traditional Arrhenius equation based on eq 3 can improve estimates of the kinetic

292

parameters for these reactions and contribute to increasing the accuracy of numerical calculations.

293

5. CONCLUSIONS

294

(1) Under conditions of continuous ventilation, when the oxygen concentration exceeds the

295

critical oxygen concentration,the full oxidative combustion reaction of a low-ranking coal will

296

reach. The decrease of the oxygen concentration will result in the decrease of the oxidation degree

297

at low-temperature oxidation. The rate of heat release during low-temperature oxidation reduces

298

with decreasing oxygen concentration; however, considering the entire reaction, the total quantity

299

of heat released is only slightly influenced by decreasing oxygen concentration and the

300

temperature at which the full oxidative combustion reaction of coal is retarded.

301

(2) During the low-temperature oxidation of low-ranking coal, three stages of kinetic

302

parameters are identified: in Stages 1 and 2, the kinetic parameters (E and A) are slightly

303

influenced by the oxygen concentration; however, in Stage 3, the apparent activation energy

304

decreases linearly and the pre-exponential factor decreases either linearly or exponentially as the

305

oxygen concentration decreases.

306

(3) In calculating the kinetic characteristics of coal under lean-oxygen conditions, revision of

307

the traditional Arrhenius equation, based on the relationships between the apparent activation

308

energy and the pre-exponential factor and oxygen concentration, can increase the accuracy of the

ACS Paragon Plus Environment

Page 14 of 34

Page 15 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

309

numerical calculations.

310

■ AUTHOR INFORMATION

311

Corresponding Author

312

*Tel.: +86 13585396491. E-mail: [email protected].

313

Notes

314

The authors declare no competing financial interest.

315

■ Acknowledgments

316

The authors wish to express their gratitude for joint funding by the National Natural Science

317

Foundation of China (No.51474210), the New Century Excellent Researcher Award Program from

318

the Ministry of Education of the People’s Republic of China (No.NCET-13-1021), special funding

319

for talent cultivation project of China University of Mining and Technology (2015YC01), the

320

Projects of Scientific Research and Innovation for the Graduates in Jiangsu Colleges and

321

Universities (SJZZ16_0273), and the Priority Academic Program Development of Jiangsu Higher

322

Education Institutions.

323

■ References

324

(1) Wang, D. Mine fires; 1th ed., China University of Mining and Technology Press: Xuzhou, 2008.

325

(2) Nimaje, D. S.; Tripathy D. P. Characterization of some Indian coals to assess their liability to spontaneous

326 327 328 329 330

combustion. Fuel 2016, 163, 139-147.

(3) Davis, J. D.; Byrne, J. F. An adiabatic method for studying spontaneous heating of coal. J. Am. Ceram. Soc.

1984, 7, 809-816.

(4) Ren, T. X.; Edwards, J. S.; Clarke, D. Adiabatic oxidation study on the propensity of pulverized coals to

spontaneous combustion. Fuel 1999, 78(14), 1611-1620.

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

331 332 333 334

(5) Beamish, B. B.; Barakat, M. A.; John, D. Adiabatic testing procedures for determining the self-heating

propensity of coal and sample ageing effects. Thermochimica Acta 2000, 362(1), 79-87.

(6) Li, L.; Beamish, B. B.; Jiang, D. Self-activation theory of spontaneous combustion of coal. J. China. Coal. Soc.

2009, 34(4), 505-508.

335

(7) Chen, X. D. On basket heating methods for obtaining exothermic reactivity of solid materials: The Extent and

336

Impact of the Departure of the Crossing-point Temperature from the Oven Temperature. Process Safety &

337

Environment Protection 1999, 77(4), 187-192.

338 339 340 341 342 343 344 345 346 347 348 349 350 351 352

(8) Jones, J. C.; Chiz, P. S.; Koh, R.; Matthew, J. Kinetic parameters of oxidation of bituminous coals from

heat-release rate measurements. Fuel 1996, 75(15), 1755-1757.

(9) Fujitsuka, H.; Ashida, R; Kawase, M.; Miura, K. Examination of low-temperature oxidation of low-rank coals,

aiming at understanding their self-lgnition tendency. Energy &Fuels 2014, 28, 2402-2407.

(10) Slovak, V.; Taraba, B. Effect of experimental conditions on parameters derived from TG-DSC measurements

of low-temperature oxidation of coal. J. Thermal Analysis and Calorimetry 2010, 101, 641-646.

(11) Wang, Q.; Guo, S; Sun, J. Spontaneous combustion prediction of coal by C80 and ARC techniques. Energy

&Fuels 2009, 23, 4871-4876.

(12) Zhao, X.; Wang, Q; Xiao, H.; Mao, Z.; Chen, P.; Sun, J. Prediction of coal stockpile autoignition delay time

using micro-calorimeter technique. Fuel Processing Technology 2013, 110, 86-93.

(13) Chen, P.; Zhang, L.; Huang, K. Kinetic modeling of coal thermal decomposition under air atmosphere. Energy

& Fuels 2016, 30, 5158-5166.

(14) Rotaru, A. Thermal analysis and kinetic study of Petroşani bituminous coal from Romania in comparison with

a sample of Ural bituminous coal. J. Thermal Analysis and Calorimetry 2012, 110(3), 1283-1291.

(15) Benfell, K. E.; Beamish, B. B.; Rodgers, K. A. Thermogravimetric analytical procedures for characterizing

ACS Paragon Plus Environment

Page 16 of 34

Page 17 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

353

New Zealand and Eastern Australian coals. Thermochimica Acta 1996, 286(1), 67-74.

354

(16) Zhang, Y.; Wu, J.; Chang, L.; Wang, J.; Xue, S.; Li, Z. Kinetic and thermodynamic studies on the mechanism

355

of low-temperature oxidation of coal: A case study of Shendong coal (China). International Journal of Coal

356

Geology 2013, 120, 41-49.

357 358

(17) Li, B.; Chen, G.; Zhang, H.; Sheng, C. Development of non-isothermal TGA–DSC for kinetics analysis of low

temperature coal oxidation prior to ignition. Fuel 2014, 118, 385-391.

359

(18) Pan, R.; Lu, C.; Yang, K.; Yu, M. Distribution regularity and numerical simulation study on the coal

360

spontaneous combustion “three zones” under the ventilation type of Ч + J. Procedia Engineering 2011, 26,

361

704-711.

362 363 364 365 366 367 368 369 370 371 372 373 374

(19) Liu, M.; Shi, G.; Guo, Z.; Wang, Y.; Ma, L. 3‑D simulation of gases transport under condition of inert gas

injection into goaf. Heat Mass Transfer 2016, 52, 2723-2734.

(20) Pan, R.; Cheng, Y.; Yu, M.; Lu, C.; Yang, K. New technological partition for ‘‘three zones’’ spontaneous coal

combustion in goaf. International Journal of Mining Science and Technology 2013, 23, 489-493.

(21) Tan, B.; Shen, J.; Zuo, D.; Guo, X. Numerical analysis of oxidation zone variation in goaf. Procedia

Engineering 2011, 26, 659-664.

(22) Wang C.; Du, Y.; Che D. Reactivities of coals and synthetic model coal under oxy-fuel conditions.

Thermochimica Acta 2013, 553, 8-15.

(23) Zhan, J.; Wang, Y.; Wang, H. The controlled reaction and dynamic analysis of the coal's mass-gain

phenomenon in coal oxidation process. Acta. Chimica. Sinica. 2012, 70(8), 980-988.

(24) Wang, Y.; Tian, Q.; Zhang, Y.; Xing, Y.; Li, S.; Wei, J. Kinetic process of low-rank coal flotation. Journal of

China University of Mining & Technology 2016, 45(2), 398-404.

(25) Tao, X. Microbial conversion of low rank coal; 1th ed., China University of Mining and Technology Press:

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

375 376 377 378 379

Xuzhou, 2013; pp 4.

(26) Rao, Z.; Zhao, Y.; Huang, C.; Duan, C.; He, J. Recent developments in drying and dewatering for low rank

coals. Progress in Energy and Combustion Science 2015, 46, 1-11.

(27) Slovak, V.; Taraba, B. Urea and CaCl2 as inhibitors of coal low-temperature oxidation. J. Thermal Analysis

and Calorimetry 2012, 110, 363-367.

380

(28) Panigrahi, D.; Sahu, H. Application of hierarchical clustering for classification of coal seams with respect to

381

their proneness to spontaneous heating. Transactions of the Institutions of Mining and Metallurgy Section

382

A-Mining Technology 2004, 113(2), 97-106.

383

(29) Zhao, X. Principle of chemical dynamics; 1th ed., Higher Education Press: Beijing, 1984; pp 112-124.

384

(30) Hu, R.; Shi, Q. Thermal analysis kinetics; 2th ed., Science Press: Beijing, 2001.

385

(31) Shen, Y.; Chen, D.; Hu, X. The present status and improvement of thermal analysis kinetics. J. South-Central

386 387 388 389 390

University for Nationnalities (Natural Science) 2002, 21(3), 11-16.

(32) Fan, S.; Sheng C. D. Impact of inorganic matter on the low-temperature oxidation of cornstalk and cellulose

chars. Energy & Fuels 2016, 30, 1783-1791.

(33) Fan, C. physical chemistry; 4th ed., Press of University of Science and Technology of China: Hefei, 2010; pp

299.

391

(34) Smith, G. C. MIT Department of Chemical Engineering; Doctoral Thesis: 1992.

392

(35) Wei, J. Adsorption and cracking of N-alkanes over ZSM-5: negative activation energy of reaction. Chem. Eng.

393 394 395

Sci. 1996, 51, 2995-2999.

(36) Wessling, S.; Kessels, W.; Schmidt, M.; Krause, U. Investigating dynamic underground coal fires by means of

numerical simulation. Geophysical Journal International 2008, 172(1), 439-454.

396

ACS Paragon Plus Environment

Page 18 of 34

Page 19 of 34

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Energy & Fuels

397

Table 1. Properties of the coal samples Properties

XJ-H

XJ-Z

PS

Mada

5.27

15.92

6.60

Aadb

Proximate analysis (%)

9.29

6.61

5.79

c

15.48

7.86

6.20

Vadd

44.74

20.68

33.21

Vdafe

48.33

26.69

37.9

40.7

56.79

54.4

C

77.04

73.97

76.88

H

5.14

3.82

3.32

N

1.30

1.37

0.61

S

1.00

0.436

0.35

O

15.52

20.38

18.84

Lower heating value (MJ/kg)

22.76

23.30

21.93

Ad

FCad

f

Ultimate analysis (%, dry ash-free basis)

398

a

Moisture of air dried basis

399

b

Ash content of air dried basis

400

c

Ash content of dried basis

401

d

Volatile of air dried basis

402

e

Volatile of dry ash-free basis

403 404

f

Fixed carbon of air dried basis

ACS Paragon Plus Environment

Energy & Fuels

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Page 20 of 34

405

Table 2. Initial exothermic temperature and heat release of XJ-Z coal of different particle sizes at oxygen

406

concentration of 21% Particle size (µm)

Toa(0C)

∆Hb (J/g)

∆HLc (J/g)

200-450

43.46

22001

1566

125-200

42.72

21951

1702

96-125

42.18

22090

1913

74-96

41.74

21803

2103