Use of Psychrotolerant Lactic Acid Bacteria - ACS Publications

Subscriber access provided by UNIV OF TEXAS DALLAS

Article

Use of psychrotolerant lactic acid bacteria (Lactobacillus spp. and Leuconostoc spp.) isolated from Chinese traditional Paocai for the quality improvement of Paocai products Aiping Liu, Xiaoyan Li, Biao Pu, Xiaolin Ao, Kang Zhou, Li He, Shujuan Chen, and Shuliang Liu J. Agric. Food Chem., Just Accepted Manuscript • DOI: 10.1021/acs.jafc.7b00050 • Publication Date (Web): 09 Mar 2017 Downloaded from http://pubs.acs.org on March 16, 2017

Just Accepted “Just Accepted” manuscripts have been peer-reviewed and accepted for publication. They are posted online prior to technical editing, formatting for publication and author proofing. The American Chemical Society provides “Just Accepted” as a free service to the research community to expedite the dissemination of scientific material as soon as possible after acceptance. “Just Accepted” manuscripts appear in full in PDF format accompanied by an HTML abstract. “Just Accepted” manuscripts have been fully peer reviewed, but should not be considered the official version of record. They are accessible to all readers and citable by the Digital Object Identifier (DOI®). “Just Accepted” is an optional service offered to authors. Therefore, the “Just Accepted” Web site may not include all articles that will be published in the journal. After a manuscript is technically edited and formatted, it will be removed from the “Just Accepted” Web site and published as an ASAP article. Note that technical editing may introduce minor changes to the manuscript text and/or graphics which could affect content, and all legal disclaimers and ethical guidelines that apply to the journal pertain. ACS cannot be held responsible for errors or consequences arising from the use of information contained in these “Just Accepted” manuscripts.

Journal of Agricultural and Food Chemistry is published by the American Chemical Society. 1155 Sixteenth Street N.W., Washington, DC 20036 Published by American Chemical Society. Copyright © American Chemical Society. However, no copyright claim is made to original U.S. Government works, or works produced by employees of any Commonwealth realm Crown government in the course of their duties.

Page 1 of 36

Journal of Agricultural and Food Chemistry

1

Use of psychrotolerant lactic acid bacteria (Lactobacillus spp. and

2

Leuconostoc spp.) isolated from Chinese traditional Paocai for the

3

quality improvement of Paocai products

4 5

Aiping Liu, Xiaoyan Li, Biao Pu, Xiaolin Ao, Kang Zhou, Li He, Shujuan Chen,

6

Shuliang Liu*

7 8

College of Food Science, Sichuan Agricultural University, Ya’an, Sichuan 625014, People’s

9

Republic of China

10 11

Corresponding Author: Shuliang Liu

12

E-mail address: [email protected]

13

Tel./Fax:+86-835-2882311

14 15 16 17 18 19 20 21 22 1

ACS Paragon Plus Environment


23

Abstract

24

In order to improve the quality of Chinese traditional Paocai, 2 psychrotolerant

25

lactic acid bacteria (LAB) strains were isolated from Paocai, and the quality of

26

Chinese Paocai product using these 2 strains as starter cultures was compared to a

27

control sample fermented with aged brine at 10 °C. The results suggested that the

28

physicochemical and sensory features of Paocai fermented with psychrotolerant LAB

29

were more suitable for industrial applications. The nitrite content of Paocai fermented

30

with psychrotolerant LAB was 1 mg/kg, which was significantly lower than that of

31

the control Paocai (P < 0.05). Low-temperature fermentation with the starter cultures

32

of psychrotolerant LAB could effectively prevent overacidity and overripening of the

33

Paocai products. Additionally, Paocai fermented with psychrotolerant LAB harbored a

34

relatively simple microbial flora as revealed by polymerase chain reaction-denaturing

35

gradient gel electrophoresis. This study provides a basis for improving the quality of

36

Chinese traditional Paocai and the large-scale production of low-temperature Chinese

37

traditional Paocai products.

38 39

Keywords: Chinese traditional Paocai; lactic acid bacteria; PCR-DGGE; starter

40

culture.

41 42 43 44 2


Page 2 of 36

Page 3 of 36


45

1 Introduction

46

Chinese traditional Paocai, believed to have originated in the Zhou Dynasty

47

3,000 years ago,1 is a well-known side-dish in China. Unlike kimchi, which uses

48

direct salting to withdraw juice from cabbage, the widely consumed Chinese

49

traditional Paocai2 is a brine-salted and lactic-acid-fermented vegetable product.3 In

50

traditional methods, Chinese Paocai is processed through spontaneous fermentation

51

without sterilization of the raw materials. This results in the proliferation of various

52

microorganisms, impeding the production of uniform and high-quality Paocai.4-6 In

53

response to this, Lactobacillus inoculants have been increasingly used as starter

54

cultures in the production of fermented vegetables in an attempt to improve quality.

55

7-10

56

Generally, mesophilic lactic acid bacteria (LAB) are widely applied in Chinese

57

traditional Paocai production.3,11 However, the greatest harvest of vegetables to be

58

salt-fermented during the production of Paocai occurs in the winter months. In this

59

period, the fermentation rate of mesophilic LAB is slow, thus slightly inhibiting the

60

growth of microbial contaminants. Consequently, high concentrations of NaCl are

61

needed to prevent vegetable spoilage, but this requirement increases production costs

62

because the finished products must subsequently be desalinated. In addition, organic

63

acids and flavor compounds may be added to fulfill the quality requirements of

64

Chinese Paocai products. These approaches not only influence the quality of Chinese

65

Paocai but also limit industrial production. Since vegetable salinization occurs in

66

winter, abundant psychrotolerant LAB may be isolated and then applied to the 3



67

production process in order to address the above-mentioned issues.

68

Recently, more and more studies have been focused on the application of

69

psychrotolerant LAB in fermented vegetables.12-16 However, to the best of our

70

knowledge, little detailed information exists on Chinese traditional Paocai prepared

71

using psychrotolerant LAB. The present study was designed to standardize the

72

fermentation and product quality of Paocai using 2 psychrotolerant LAB strains. The

73

2 strains, namely, 3m-1 (Lactobacillus plantarum, L. plantarum) and 8m-9

74

(Leuconostoc mesenteroides, L. mesenteroides), were isolated from Paocai products in

75

Sichuan by the serial plate dilution method at 10 °C. Afterward, the Paocai was

76

fermented with the starter cultures of these 2 psychrotolerant LAB, and the resulting

77

product was compared to a control sample fermented with aged brine at 10 °C. The

78

physicochemical characteristics, sensory features, microflora composition, and

79

volatile flavor compounds of the products were investigated. The detailed profiling

80

presented in this work will serve an important role in industrial applications.

81

2 Materials and Methods

82

2.1 Materials

83

Cabbages (Brassica pekinensis) were purchased from a local market in Ya’an,

84

Sichuan, China and used as the raw materials for fermentation. The outer leaves and

85

inedible parts were removed. The aged brine used for the isolation of psychrotolerant

86

LAB included 10 portions of locally ripened traditional Chinese Paocai products

87

(spontaneously fermented) obtained from Chengdu, Meishan and Yaan cities in the

88

Sichuan province. The aged brine was 3 to 5 years old, and contained 3% to 10% 4


Page 4 of 36

Page 5 of 36


89

NaCl (W/V). The total aerobic and LAB counts were between 6.5 and 7.5 lg CFU/mL,

90

respectively, and the yeast count was between 6.0 and 7.0 lg CFU/mL. The aged brine

91

used for Paocai (2#) preparation comprised a mixture of 4 equal amounts of the above

92

aged brine collected from Yaan city.

93

2.2 Isolation and characterization of psychrotolerant LAB

94

Briefly, the aged brine was inoculated into De Man Ragosa Sharpe (MRS) broth

95

(pH 6.2-6.4) and kept at 10 °C for 96 h. The appropriate dilutions were prepared from

96

the culture. Dilutions were plated by using MRS agar (MRS broth containing 1.2%

97

agar) containing 1.5% CaCO3 via the pour plate method. Representative colonies with

98

a dissolved calcium circle were randomly picked and purified. Gram-positive,

99

catalase-negative isolates were considered as presumptive LAB isolates, and further

100

screened by investigating growth status at 9, 8, 7, 6, 5, 4, 3 and 2 °C for 96 h,

101

respectively. Those isolates with high tolerance to low temperatures were selected. In

102

order to investigate whether the final isolates belonged to psychrotolerant LAB, the

103

isolates at a density of 108 CFU/mL were inoculated into MRS broth (0.3%, V/V ),

104

and growth at 2, 5, 8, 10, 15, 20, 25, 30, 34 and 37 °C was monitored for 48 h.

105

Phenotypic

106

gelatin liquefaction, litmus milk tests; acid production from aescinate, cellobiose,

107

maltose, mannitol, salicin, sorbitol, sucrose, raffinose, inulin, lactose, melibiose,

108

mannose, galactose, rhamnose, fructose, and xylose; growth at 15 °C; and tolerance to

109

NaCl (2%, 4%, 6%, 8%, 10%, 12%, 14% and 16%, W/V), with reference to Ren et al.

110

17

characteristics were assessed using several methods, including oxidase,

The isolates were sent to Sangon Biotech (Shanghai, China) for genus and species 5



111

identification by 16S rRNA gene sequence analysis. The nitrite degradation

112

characteristics of the final isolates (strains 8m-9 and 3m-1) were also studied

113

according to the method of Oh et al.18 The original concentration of nitrite used for

114

degradation was 125 µg/mL, and the nitrite content was examined every 12 h using

115

hydrochloride naphthodiamide.19

116

2.3 Preparation of starter cultures

117

Strains 8m-9 and 3m-1 were activated on MRS agar for 2 d at 30 °C. The

118

colonies of each strain were inoculated into MRS broth and the cultures were

119

incubated at 30 °C for 24 h. The cell pellets were harvested and washed twice with

120

0.9% saline. Afterward, the pellets were resuspended at a density of 1010 CFU/mL in

121

0.9% saline.

122

2.4 Paocai preparation

123

Paocai was prepared using 2 different recipes. Paocai (1#) was processed as

124

follows. Cabbages (1 kg) were washed with cooled boiled water, dried, cut into strips

125

(2-4 cm × 5-10 cm) and placed in a 3 L ceramic jar. An equal amount of cooled boiled

126

water containing 5% NaCl, 2% sucrose, 16% seasoning liquid, 0.3% CaCl2, and 1%

127

Chinese liquor (50%, V/V, Langjiu, Sichuan Gulin langjiu Distillery Co., Ltd.,

128

Sichuan, China) was added. Then, 0.3% (V/V) of mixed starter cultures (3m-1:8m-9 =

129

2:1, V/V) at a density of 1010 CFU/mL were added. The jar was covered with a lid and

130

water-sealed. The preparation of Paocai (2#), used as a control sample, was similar to

131

that of Paocai (1#) except that the cell suspension and cooled boiled water were

132

replaced with double diluted aged brine (diluted in cooled boiled water). All jars were 6


Page 6 of 36

Page 7 of 36


133

kept at 10 °C. The seasoning liquid was prepared as follows: 12 g of Chinese Wang

134

Shouyi thirteen spice powder (W/V, mainly contains pepper, dried ginger, cinnamon,

135

star anise, garlic, fennel, cardamom, Pericarpium Citri Reticulatae [Chenpi in

136

Chinese], Angelicae Dahuricae Radix [Baizhi in Chinese], Radix Aucklandiae

137

[Muxiang in Chinese], and Syzygium aromaticum [Dingxiang in Chinese]; purchased

138

from Zhumadian Wang Shouyi Shi San Xiang Multi-flavored Spice Group Co., Ltd,

139

Henan, China) were wrapped in a cloth bag and heated in 100 mL of water at 80 °C

140

for 3 h, and the collected supernatant constituted the seasoning liquid.

141

2.5 Sampling and analysis of physicochemical characteristics

142

The pickled cabbages and brine from Paocai (1#) and (2#) were aseptically

143

collected at the same time points on day 0, 1, 2, 3, 4, 5, 7, 9, 11, 13, 15 and 20 in order

144

to monitor the physicochemical characteristics. The jars were shaken prior to

145

sampling. Each analysis was performed with homogenized cabbages and brine in

146

triplicate, and the average result was reported.

147

2.5.1 pH, nitrite and reducing sugar contents

148

The pH was determined using a pH meter (Cyberscan PC 510, Eutech, Shanghai,

149

China). The concentration of nitrite per kg was determined using hydrochloride

150

naphthodiamide19. The reducing sugar was determined using a direct titration method

151

with alkaline copper tartrate, as described by Hao et al.20

152

2.5.2 Titratable acidity

153

A 200 g of homogenized sample was mixed with an equal amount of cooled

154

boiled water for 20 min, and the mixture was filtered using Whatman filter paper. 7



155

Titratable acidity was determined by titrating the filtrate with 0.1 M NaOH using

156

phenolphthalein (1% in 57% ethanol) as an indicator.

157

2.5.3 Salinity

158

The concentration of sodium chloride was determined as follows. First, 2 mL of

159

the filtrate from the homogenized sample was mixed with 50 mL deionized water and

160

1 mL potassium chromate (0.26 mol/L). The resulting mixture was titrated with

161

standardized 0.1 mol/L silver nitrate until an orange color developed, and 50 mL of

162

deionized water was used as a control. The concentration of sodium chloride was

163

calculated as

164

X=

( v1 − v2 ) × c × 0.0585 × 100 v m× 3 100

165

where X is the concentration of sodium chloride (g/100 g), v1 is the volume (mL)

166

of the silver nitrate solution used to titrate the filtrate, v2 is the volume (mL) of the

167

silver nitrate solution used to titrate 50 mL of deionized water, v3 is the volume (mL)

168

of the filtrate, c is the concentration of standardized solution of silver nitrate, m is the

169

weight (g) of the sample, and 0.0585 represents the weight of sodium chloride that is

170

equal to 1 mL of the standardized silver nitrate solution.

171

2.5.4 Lactic acid and acetic acid contents

172

Mashed samples from Paocai (1#), collected on day 1, 2, 3, 5 and 9, and Paocai

173

(2#), collected on day 1, 2, 3, 5 and 11, were diluted to 50 mL in volumetric flasks for

174

measurement. After soaking for 1 h, the solution was passed through filter paper and

175

centrifuged at 10,000 × g for 5 min. The resulting supernatant was further

176

membrane-filtered (0.45 µm) and injected into a Shimadzu HPLC (LC-10A2010C HT, 8


Page 8 of 36

Page 9 of 36


177

Japan) equipped with UV detector, which was set at 210 nm. A Carbomix H-NP

178

column with 8% crosslinking (7.8 × 300 mm, 10 µm, Sepax Technologies, Inc.,

179

Newark, DE) was used. The mobile phase was 2.5 mM H2SO4 at a flow rate of 0.6

180

mL/min. The column temperature was 58 °C. The calibration curve was established

181

and the concentration versus peak area was calculated according to the least-squares

182

method.

183

2.6 Sensory analysis

184

Sensory analysis was performed on the day when the ripened Paocai product was

185

obtained. Panelists were trained to be familiar with the attributes of Paocai products,

186

and several sensory characteristics, including appearance, color, odor, taste and

187

texture were evaluated by 10 trained panelists on either a 10-point (appearance, color

188

and odor) or 30-point (taste and texture) scale. On both scales, 1 represented the

189

lowest score, while either 10 or 30 represented the highest score. The products were

190

coded with random numbers and presented to the panelists on a tray. The serving

191

orders were randomized, and water was provided between samples to cleanse the

192

palate.20-23

193

2.7 Microbial analysis

194

2.7.1 Enumeration of microorganisms

195

Samples (0, 1, 2, 3, 4, 5, 7, 9, 11, 13, 15, and 20 d) from Paocai (1#) and (2#)

196

were removed aseptically, and 25 g of the sample was mixed with 225 mL of 0.9%

197

NaCl. Further serial decimal dilutions were prepared from this mixture. The following

198

incubation conditions were used: plate count agar for 2 d at 37 °C for total aerobes, 9



Page 10 of 36

199

MRS agar for 2 d at 37 °C (anaerobic) for LAB, potato dextrose agar for 5 d at 28 °C

200

for mold-yeasts, and violet red bile agar for 2 d at 37 °C for total coliforms. All

201

analyses were performed in triplicate and the mean values were calculated.

202

2.7.2 Microflora composition

203

Samples from Paocai (1#), collected on day 1, 2, 3, 5 and 9, and Paocai (2#),

204

collected on day 1, 2, 3, 5 and 11 were analyzed through polymerase chain

205

reaction-denaturing gradient gel electrophoresis (PCR-DGGE) according to the

206

method presented by Liu et al.24 The 16S and 18S rDNA were ampliﬁed in 2 rounds

207

of PCR, using primers A (F338-GC, 5'-CGCCCGCCGCGCGCGGCGGGCGGGGC

208 209 210

GGGGGCACGGGGGGACTCCTACGGGAGGCAGCAG-3',

and

R518,

5'-GTATTACCGCGGCTGCTGG-3') and primers B (F1427-GC, 5'-CGCCCGCCG CGCGCGGCGGGCGGGGCGGGGGCACGGGGGGTCTGTGATGCCCTTAG

211

ATGTTCTGGG-3',

and

212

respectively.

213

2.8 Volatile flavor compounds

R1616,

5'-GGTGTGTACAAAGGGCAGGG-3'),

214

The samples were pretreated for solid-phase microextraction (SPME) analysis as

215

reported by Zheng et al.25 In brief, ground raw materials (5 g) and samples (5 g) from

216

Paocai (1#), collected on day 5 and 9, and Paocai (2#), collected on day 5 and 11,

217

respectively, were placed in a 40-mL vial sealed with a PTFE/silicone septum

218

(Supelco). Each vial was stored at 40 °C to equilibrate for 30 min in a water bath.

219

Divinylbenzene/carboxen/polydimethylsiloxane

220

exposed to adsorb the analytes for 30 min. Afterward, the fiber was withdrawn from

(DVB/CAR/PDMS)

10


fiber

was

Page 11 of 36


221

the needle, and introduced to a heated gas chromatograph injector for desorption and

222

analysis. The fiber was held for 5 min in the injection port to desorb volatile

223

compounds.

224

Gas chromatography-mass spectrometry (GC-MS; Agilent-7890A-5975C;

225

Agilent, USA) with an elastic capillary vessel column (HP-5MS, 30 m × 0.25 mm i.d.,

226

0.25 µm film thickness) was utilized to analyze the volatile flavor compounds.

227

Thermal desorption of the compounds from the fiber coating took place in the GC

228

injector at 250 °C in splitless mode. Helium was used as the carrier gas at a flow

229

velocity of 1 mL/min. The oven temperature gradient was programmed as follows:

230

30 °C held for 2 min, then raised to 155 °C at a rate of 2 °C /min; raised to 180 °C at a

231

rate of 5 °C/min; raised to 250 °C at a rate of 10 °C/min; and then held for 3 min. The

232

mass spectra was obtained with a source temperature of 230 °C and a 70 eV

233

ionization potential. The mass scan range was 30-400 AMU. Compounds were

234

identified using the National Institute of Standards and Technology (NIST) library and

235

profile

236

determined by area normalization.

237

2.9 Statistical analysis

analysis

(similarity

index>80).

The relative content of each peak was

238

Each Paocai product was prepared and characterized with three independent

239

replications. Mean and standard deviations were calculated and subjected to one-way

240

ANOVA using SPSS 18.0. Statistical significance was determined at the 5% level (P
0.05)

276

in both Paocai products. By contrast, the increase in the titratable acidity in Paocai (1#)

277

was slower than that in Paocai (2#) (P < 0.05). Considering the pH and sensory

278

evaluation of Paocai, well-ripened products from Paocai (1#) and (2#) were obtained

279

on day 9 and 11, respectively. The suitable pH of Paocai (1#) stabilized after the

280

ripening period, which contributed to an extended shelf life.8 The pH of Paocai (2#)

281

declined from 3.63 to 3.51 after ripening but changed little thereafter. Initially, the

282

salinity of both Paocai products increased. However, the salinity of Paocai (1#)

283

reached a maximum of approximately 2.7% on day 5 and remained steady (P > 0.05),

284

while the salinity of Paocai (2#) did not vary (P > 0.05) until day 15. The salinity of

285

Paocai (1#) was much lower than that of Paocai (2#).

286

In the initial stage of fermentation, nitrate was transformed into nitrite as a result 13



the

growth

of

nitrate-reducing

bacteria.

As

fermentation

Page 14 of 36

287

of

proceeded,

288

nitrate-reducing bacteria were inhibited and nitrite was decomposed by LAB.

289

Therefore, a decreasing trend in nitrite content was observed after the initial increase.

290

The greatest nitrite content in Paocai (1#) was observed prior to that of Paocai (2#),

291

and Paocai (1#) exhibited a smaller chromatographic peak possibly because the starter

292

cultures, especially 3m-1, encoded a better degradation capacity for nitrite. It is worth

293

noting that the nitrite content in ripened Paocai (1#) was close to the detection limit of

294

the method employed (1 mg/kg), and lower than most of previous reports.11,

295

Additionally, the nitrite content of ripened Paocai (2#) (2.5 mg/kg) also satisfied the

296

local standard for Paocai (20 mg/kg).

28

297

Before ripening, the contents of lactic acid and acetic acid were investigated. As

298

shown in Figure 3, the lactic acid content in Paocai (2#) increased, while the lactic acid

299

content in Paocai (1#) did not vary (P > 0.05) after day 5. The acetic acid content of

300

both Paocai products increased over the course of the entire study. Although the

301

increase in lactic acid and acetic acid contents was more rapid (P < 0.05) in Paocai (1#)

302

than in Paocai (2#) from day 2 to day 5, the final concentrations of lactic acid and acetic

303

acid in Paocai (2#) were much higher. As a consequence, Paocai (2#) was overripe.

304

These changes were consistent with the pH and titratable acidity values, thus it was

305

determined that low-temperature fermentation with the starter cultures of

306

psychrotolerant LAB could effectively prevent overacidity and overripening of Paocai

307

products.

308

3.3 Sensory analysis 14


Page 15 of 36


309

The sensory evaluation of both Paocai products was shown in Figure 4. As

310

depicted, there were no significant differences in appearance, color or texture of the 2

311

products (P>0.0.5). Conversely, the odor and taste of Paocai (1#) was better than that

312

of Paocai (2#) (P < 0.0.5), and this finding was consistent with both the

313

physicochemical characteristics as well as the analysis of volatile flavor compounds.

314

Therefore, fermentation with the psychrotolerant LAB starter cultures could

315

standardize and improve the product quality.

316

3.4 Microbial analysis

317

3.4.1 Microbial counts

318

The changes in LAB, total aerobes and yeast counts in both Paocai products

319

during fermentation were shown in Figure 5. As LAB comprised the predominant

320

microbes and were able to propagate on PCA plates, the changes in LAB and total

321

aerobes in both Paocai products showed a similar tendency. During the first 2 days,

322

the psychrotolerant LAB inoculated in Paocai (1#) adapted rapidly to the

323

low-temperature environment. Thus, the CFU value of LAB increased exponentially

324

and reached a maximum. As a result, yeast growth was inhibited. However, the LAB

325

count in Paocai (2#) was less (106 CFU/g) and comprised multiple species. Yeast

326

exhibited a certain resistance to cold, thus explaining their increase. After 2 d, LAB

327

and total aerobe counts decreased slowly in both Paocai products (P > 0.05), while

328

yeast counts increased due to the weakened inhibition from the LAB. After 4 d, LAB

329

inhibited by the low-temperature continued to grow, and there was a slow increase in

330

LAB and total aerobe counts. During the later period of the fermentation process, 15



331

LAB and total aerobe counts decreased sharply and then began to stabilize as a result

332

of the accumulation of metabolites and nutrient consumption.

333

Additionally, in order to assess the microbiological quality of the products,

334

counts of total coliforms in both Paocai products were investigated (Table 2). Mold

335

counts were always found to be lower than 10 CFU/g (data not shown). The number

336

of LAB in Paocai (1#) was greater than that in Paocai (2#) during the entire

337

fermentation process, whereas the number of yeast exhibited the opposite tendency. In

338

summary, low temperatures can reduce microbial contamination.

339

3.4.2 Microflora composition

340

A secondary PCR was performed to obtain adequate PCR products for a

341

successful DGGE analysis. Figure 6(A) indicated the DGGE profile of bacterial

342

diversity at different periods during fermentation. As depicted in Figure 6, certain

343

differences were observed in the bacterial diversity of both Paocai products. The

344

evident bands on the DGGE gel were reclaimed, amplified through PCR, and then

345

purified. The resulting products were ligated to a T-vector and transformed into E.

346

coli DH5a. Single colonies were collected and sent for sequencing. Table S1(A) listed

347

the types of bacteria identified based on the detectable DGGE bands. During

348

fermentation, the predominant LAB in both Paocai products were L. mesenteroides

349

and L. plantarum. The predominant LAB in aged brine were consistent with that

350

found by Xiong et al.29 Interestingly, Staphylococcus was observed in both Paocai

351

products, but the counts decreased over time in Paocai (1#) and were stagnant in

352

Paocai (2#). Figure 6(B) and (C) illustrated the similarity indices of the DGGE 16


Page 16 of 36

Page 17 of 36


353

profiles of bacteria in Paocai (1#) and (2#). The bacterial populations differed

354

considerably during fermentation.

355

The DGGE profile of fungal diversity at different periods during fermentation

356

was shown in Figure 7. Table S1(B) listed the types of fungi identified based on the

357

detectable bands on DGGE. The main fungal flora detected was yeast, however,

358

reports on the molecular diversity of yeast in pickled cabbages were few. Compared

359

with the 14 types of yeast in our research, Chang et al.30 identified 8 types of yeast in

360

kimchi, but only Kluyveromyces marxianus was found in both studies. Figure 7(B)

361

and (C) illustrated the similarity indices of the DGGE profiles of fungi. The overall

362

similarity coefficient in the DGGE profile of fungi was higher than that of bacteria,

363

indicating that there was less variation in fungal genera. This observation was

364

consistent with the work of Chang et al.30

365

3.5 Volatile flavor compounds

366

The number of volatile flavor compounds and their relative percentage

367

composition in both Paocai products were shown in Table 3. Both Paocai products

368

were rich in volatile flavor compounds, such as esters, acids, alcohols and aldehydes,

369

which was similar to the findings of Wu et al.31 The main categories of volatile flavor

370

compounds included olefins, esters, alcohols and sulfides, and their relative contents

371

accounted for more than 90%. As fermentation proceeded, the total number of volatile

372

compounds increased due to chemical and enzymatic reactions or microbial

373

metabolites,32 and the total number and content of compounds in Paocai (1#) was

374

slightly more than that in Paocai (2#). 17



375

Sulfur compounds played an important role in determining the flavor quality of

376

kimchi products.33,

34

377

cabbage, radish, red pepper, gar garlic, ginger, and green onion.35 Ha et al.36 revealed

378

that the main flavor compound in kimchi fermented at 5 °C was dimethyl trisulfide,

379

which was also one of the sulfides identified in both Paocai products in our research.

380

This indicated that dimethyl trisulfide might also exert a certain influence on the

381

flavor of Paocai in the present study. The relative contents of esters and alcohols in

382

Paocai (2#) were lower than that of Paocai (1#), which might be associated with the

383

structure of the microflora.

The sulfur compounds in kimchi originated from Chinese

384

In summary, 2 psychrotolerant LAB strains were isolated and used for Paocai

385

production. Additionally, a detailed comparative study between Paocai fermented with

386

the starter cultures of these 2 psychrotolerant LAB and Paocai fermented with aged

387

brine was conducted. The results of this study could be helpful to the industrial

388

production of high-quality Chinese traditional Paocai. However, in order to provide a

389

reliable basis for the industrial production, future work should focus on the quality

390

control of various batches of products, quality comparisons among more products in

391

the market and whether they are typical of standard processed material.

392 393 394 395 396 18


Page 18 of 36

Page 19 of 36


397

Abbreviation Used

398

GC-MS, gas chromatography-mass spectrometry; LAB, lactic acid bacteria; MRS, De

399

Man Ragosa Sharpe; PCR-DGGE, polymerase chain reaction-denaturing gradient gel

400

electrophoresis.

401 402

Supporting Information Description

403

Table S1(A) Type of bacterial communities corresponding to the bands in Figure

404

6(A).

405

Table S1(B) Type of fungal communities corresponding to the bands in Figure 7(A).

406 407

Funding Support

408

The work was supported by the National Natural Science Foundation of China

409

(No. 31171726) and the Science & Technology Foundation of Sichuan Province

410

(14NZ0012, 2013NZ0055).

411 412 413 414 415 416 417 418 19



419

References

420

1. Zhang, S.S. Chinese pickles. Higher education press: Beijing, China, 1994.

421

2. Zhao, N.; Zhang, C.; Yang, Q.; Guo, Z.; Yang, B.; Lu, W.; Li, D.; Tian, F.; Liu X.;

422

Zhang, H.; Chen, W. Selection of Taste Markers Related to Lactic Acid Bacteria

423

Microflora Metabolism for Chinese Traditional Paocai: A Gas Chromatography–Mass

424

Spectrometry-Based Metabolomics Approach. J Agric Food Chem, 2016, 64,

425

2415-2422.

426

3. Xiong, T.; Li, J.; Liang, F.; Wang, Y.; Guan, Q.; Xie, M. Effects of salt

427

concentration on Chinese sauerkraut fermentation. LWT-Food Sci Technol, 2016, 69,

428

169-174.

429

4. Cagno, R.D.; Coda, R.; Angelis, M.D.; Gobbetti, M. Exploitation of vegetables and

430

fruits through lactic acid fermentation. Food Microbiol, 2013, 33, 1-10.

431

5. Lee, M.E.; Jang, J.Y.; Lee, J.H.; Park, H.W.; Choi, H.J.; Kim, T.W. Starter cultures

432

for kimchi fermentation. J Microbiol Biotechnol, 2015, 25, 559-568.

433

6. Moon, S.H.; Moon, J.S.; Chang, H.C. Rapid manufacture and quality evaluation of

434

long-term fermented kimchi (mukeunji) using Lactobacillus sakei SC1. Food Sci

435

Biotechnol, 2015, 24, 1797-1804.

436

7. Chang, J.Y.; Chang, H.C. Improvements in the Quality and Shelf Life of Kimchi by

437

Fermentation with the Induced Bacteriocin-Producing Strain, Leuconostoc citreum

438

GJ7 as a Starter. J Food Sci, 2010, 75, M103-M10.

439

8. Jang, J.Y.; Lee, M.E.; Lee, H.W.; Lee, J.H.; Park, H.W.; Choi, H.J.; Pyun, Y.R.;

440

Kim, T.W. Extending the shelf life of kimchi with Lactococcus lactis strain as a starter 20


Page 20 of 36

Page 21 of 36


441

culture. Food Sci Biotechnol, 2015, 24, 1049-1053.

442

9. Jo, S.Y.; Choi, E.A.; Lee, J.J.; Chang, H.C. Characterization of starter kimchi

443

fermented with Leuconostoc kimchii GJ2 and its cholesterol-lowering effects in rats

444

fed a high-fat and high-cholesterol diet. J Sci Food Agr, 2015, 95, 2750-2756.

445

10. Yan, P.M.; Xue, W.T.; Tan, S.S.; Zhang, H.; Chang, X.H. Effect of inoculating

446

lactic acid bacteria starter cultures on the nitrite concentration of fermenting Chinese

447

paocai. Food control, 2008, 19, 50-55.

448

11. Jung, J.; Lee, H.; Jeon, O. Kimchi microflora: history, current status, and

449

perspectives for industrial kimchi production. Appl Microbiol Biotechnol, 2014, 98,

450

2385-2393.

451

12. Ahn, G.H.; Moon, J.S.; Shin, S.Y.; Min, WK.; Han, N.S.; Seo, J.H. A competitive

452

quantitative polymerase chain reaction method for characterizing the population

453

dynamics during kimchi fermentation. J Ind Microbiol Biot, 2015, 42, 49-55.

454

13. Eom, H.; Seo, D.; Han, N. Selection of psychrotrophic Leuconostoc spp. producing

455

highly active dextransucrase from lactate fermented vegetables. Int J Food Microbiol,

456

2007, 117, 61-67.

457

14. Jung, J.Y.; Lee, S.H.; Lee, H.J.; Seo, H.Y.; Park, W.S.; Jeon, CO. Effects of

458

Leuconostoc mesenteroides starter cultures on microbial communities and metabolites

459

during kimchi fermentation. Int J Food Microbiol, 2012, 153, 378-387.

460

15. Kyung, K.H.; Medina Pradas, E.; Kim, S.G.; Lee, Y.J.; Kim, K.H.; Choi, J.J.; Cho,

461

J.H.; Chung, C.H.; Barrangou, R.; Breidt, F. Microbial ecology of watery kimchi. J

462

Food Sci, 2015, 80, M1031-M1038. 21



463

16. Park, J.M.; Shin, J.H.; Lee, D.W.; Song, J.C.; Suh, H.J.; Chang, U.J.; Kim, J.M.

464

Identification of the lactic acid bacteria in kimchi according to initial and over-ripened

465

fermentation using PCR and 16S rRNA gene sequence analysis. Food Sci Biotechnol,

466

2010, 19, 541-546.

467

17. Ren, X.; Li, M.; Guo, D. Enterococcus Xinjiangensis sp. nov., isolated from

468

Yogurt of Xinjiang, China. Curr Microbiol, 2016, 73, 374-378.

469

18. Oh, C.; Oh, M.; Kim, S. The depletion of sodium nitrite by lactic acid bacteria

470

isolated from kimchi. J Med Food, 2004, 7, 38-44.

471

19. Du, S.; Wu, J.R.; Sun, X.; Yue, X. Effect of the change of nitrite content in natural

472

fermentation on the edible security of Chinese sauerkraut. Adv Mater Res, 2013, 726,

473

859-862.

474

20. Hao, L.; Zhang, J.; Lu, J.; Ba, J.; Yu, J. Characterization of a new Polysaccharide

475

from potato starch. J Food Process Pres, 2014, 38, 1409-1415.

476

21. Liu, H.; Xu, X.; Guo, S.D. Rheological, texture and sensory properties of low-fat

477

mayonnaise with different fat mimetics. LWT-Food Sci Technol, 2007, 40, 946-954.

478

22. Worrasinchai, S.; Suphantharika, M.; Pinjai, S.; Jamnong, P. β-Glucan prepared

479

from spent brewer's yeast as a fat replacer in mayonnaise. Food Hydrocolloids, 2006,

480

20, 68-78.

481

23. Yazici, F.; Akgun, A. Effect of some protein based fat replacers on physical,

482

chemical, textural, and sensory properties of strained yoghurt. J Food Eng, 2004, 62,

483

245-254.

484

24. Liu, A.; Peng, Z.; Zou, L.; Zhou, K.; Ao, X.; He, L.; Chen, S.; Liu, S. The effects 22


Page 22 of 36

Page 23 of 36


485

of lactic acid-based spray washing on bacterial profile and quality of chicken

486

carcasses. Food Control, 2016, 60, 615-620.

487

25. Zheng, J.; Zhang, F.; Zhou, C.; Lin, M.; Kan, J. Comparison of flavor compounds

488

in fresh and pickled bamboo shoots by GC-MS and GC-olfactometry. Food Sci

489

Technol Res, 2014, 20, 129-138.

490

26. Master, E.R.; Mohn, W.W. Psychrotolerant bacteria isolated from Arctic soil that

491

degrade polychlorinated biphenyls at low temperatures. Appl Environ Microb, 1998,

492

64, 4823-4829.

493

27. Morita, R.Y. Psychrophilic bacteria. Bacteriol Rev, 1975, 39, 144-167.

494

28. Suh, J.; Paek, O.J.; Kang, Y.; Ahn, J.E.; Jung, J.S.; An, Y.S.; Park, S.H.; Lee, S.J.;

495

Lee, K.H. Risk Assessment on Nitrate and Nitrite in Vegetables Available in Korean

496

Diet. J Appl Biol Chem, 2013, 56, 205-211.

497

29. Xiong, T.; Song, S., Huang, X.; Feng, C.; Liu, G.; Huang, J.; Xie, M. Screening

498

and identification of functional Lactobacillus specific for vegetable fermentation. J

499

Food Sci, 2013, 78, M84-M89.

500

30. Chang, H.; Kim, K.; Nam, Y.; Roh, S.; Kim, M.; Jeon, C.; Oh, H.; Bae, J. Analysis

501

of yeast and archaeal population dynamics in kimchi using denaturing gradient gel

502

electrophoresis. Int J Food Microbiol, 2008 ,126, 159-66.

503

31. Wu, R.; Yu, M.; Liu, X.; Meng, L.; Wang, Q.; Xue, Y.; Wu, J.; Yue, X. Changes in

504

flavour and microbial diversity during natural fermentation of suan-cai, a traditional

505

food made in Northeast China. Int J Food Microbiol, 2015, 211, 23-31.

506

32. Zhao, D.; Tang, J.; Ding, X. Analysis of volatile components during potherb 23



507

mustard (Brassica juncea, Coss.) pickle fermentation using SPME–GC-MS.

508

LWT-Food Sci Technol, 2007, 40, 439-447.

509

33. Cha, Y.; Kim, H.; Cadwallader, K. Aroma-active compounds in kimchi during

510

fermentation. J Agr Food Chem, 1998, 46, 1944-1953.

511

34. Hawer, W.S. A study on the analysis of volatile flavor of Kimchee. Anal Sci

512

Technol, 1994, 7, 125-132.

513

35. Block, E.; Naganathan, S.; Putman, D.; Zhao, S. Allium chemistry: HPLC analysis

514

of thiosulfinates form onion, garlic, wild garlic (Ramsons), leek, scallion, shallot,

515

elephant (Great-headed) garlic, chive and Chinese chive. Uniquely high ally to methyl

516

rations in some garlic samples. J Agric Food Chem, 1992, 40, 2418-2430.

517

36. Ha, J.H.; Seog, H.M.; Nam, Y.J.; Shin, D.W. Changes in the taste and flavour

518

compounds of kimchi during fermentation. Korean J Food Sci Technol, 1988, 20,

519

511-517.

520 521 522 523 524 525 526 527 528 24


Page 24 of 36

Page 25 of 36


529

Figure captions

530

Figure 1. The OD600nm value of strains 3m-1 and 8m-9 broth after incubation at

531

different temperatures for 48 h.

532

Figure 2. Changes in pH, titratable acidity, salinity, and nitrite and reducing sugar

533

contents of both Paocai products during fermentation.

534

(A) Paocai (1#). (B) Paocai (2#).

535

Figure 3. Changes in lactic acid (A) and acetic acid (B) contents in both Paocai

536

products during fermentation.

537

Figure 4. Sensory evaluation of Paocai products.

538

Figure 5. Changes in total aerobes, LAB, and yeast counts in both Paocai products

539

throughout fermentation.

540

(A) Paocai (1#). (B) Paocai (2#).

541

Figure 6. DGGE profile of PCR-amplified 16S rDNA and cluster analysis of DGGE

542

profile.

543

(A) DGGE profile of PCR-amplified 16S rDNA from Paocai (1#) and (2#). (B)

544

Cluster analysis of DGGE profile for Paocai (1#). (C) Cluster analysis of DGGE

545

profile for Paocai (2#).

546

Figure 7. DGGE profile of PCR-amplified 18S rDNA and cluster analysis of DGGE

547

profile.

548

(A) DGGE profile of PCR-amplified 18S rDNA from Paocai (1#) and (2#). (B)

549

Cluster analysis of DGGE profile for Paocai (1#). (C) Cluster analysis of DGGE

550

profile for Paocai (2#). 25



Page 26 of 36

Tables Table 1 The properties of strain 3m-1 and 8m-9 Strain 3m-1

Result

Strain 8m-9

Result

Catalase test

-

Catalase test

-

Oxidase

-

Oxidase

-

Grow at

Gelatin liquefaction

-

Litmus milk

-

Grow at

15 °C

+

14% NaCl

+

Decarboxylase (Lysine, Ornithine, and arginine)

10% NaCl Decarboxylase (Lysine,

-

Ornithine, and arginine)

+

-

Acid produced from

+

Acid produced from

Aescinate

+

Fructose

+

Cellobiose

+

Galactose

+

Maltose

+

Lactose

+

Mannitol

+

Maltose

+

Salicin

+

Mannose

+

Sorbitol

+

Xylose

+

Sucrose

+

Sucrose

+

Raffinose

+

Inulin

+

Lactose

+

Melibiose

+

Mannose

+

Galactose

-

Rhamnose

+

Symbols: “＋”, positive; “-”, negative.

26


Page 27 of 36


Table 2 The maximum probable number of total coliforms (CFU/100 g) Time (d)

1

2

3

4

5

7

9

11

13

15

20

Paocai (1#)

610

172

Use of Psychrotolerant Lactic Acid Bacteria - ACS Publications

Recommend Documents