Effects of Lipids on in Vitro Release and Cellular ... - ACS Publications

Subscriber access provided by UNIV LAVAL

Article

Effects of lipids on in vitro release and cellular uptake of #-carotene in nanoemulsion-based delivery system Jiang Yi, Fang Zhong, Yuzhu Zhang, Wallace Yokoyama, and Liqing Zhao J. Agric. Food Chem., Just Accepted Manuscript • DOI: 10.1021/acs.jafc.5b04789 • Publication Date (Web): 02 Dec 2015 Downloaded from http://pubs.acs.org on December 4, 2015

Just Accepted “Just Accepted” manuscripts have been peer-reviewed and accepted for publication. They are posted online prior to technical editing, formatting for publication and author proofing. The American Chemical Society provides “Just Accepted” as a free service to the research community to expedite the dissemination of scientific material as soon as possible after acceptance. “Just Accepted” manuscripts appear in full in PDF format accompanied by an HTML abstract. “Just Accepted” manuscripts have been fully peer reviewed, but should not be considered the official version of record. They are accessible to all readers and citable by the Digital Object Identifier (DOI®). “Just Accepted” is an optional service offered to authors. Therefore, the “Just Accepted” Web site may not include all articles that will be published in the journal. After a manuscript is technically edited and formatted, it will be removed from the “Just Accepted” Web site and published as an ASAP article. Note that technical editing may introduce minor changes to the manuscript text and/or graphics which could affect content, and all legal disclaimers and ethical guidelines that apply to the journal pertain. ACS cannot be held responsible for errors or consequences arising from the use of information contained in these “Just Accepted” manuscripts.

Journal of Agricultural and Food Chemistry is published by the American Chemical Society. 1155 Sixteenth Street N.W., Washington, DC 20036 Published by American Chemical Society. Copyright © American Chemical Society. However, no copyright claim is made to original U.S. Government works, or works produced by employees of any Commonwealth realm Crown government in the course of their duties.

Page 1 of 35

Journal of Agricultural and Food Chemistry

1

Effects of lipids on in vitro release and cellular uptake of β-carotene in nanoemulsion-

2

based delivery system

3

Jiang Yi1*, Fang Zhong2, Yuzhu Zhang3, Wallace Yokoyama3, Liqing Zhao1*

4

1

5

2

6

and Technology, Jiangnan University, Wuxi 214122, China

7

3

College of chemistry and environmental engineering, Shenzhen University, Shenzhen 518060, China Key Laboratory of Food Colloids and Biotechnology, Ministry of Education, School of Food Science

Western Regional Research Center, ARS, USDA, Albany, California 94710, United States

8 9 10 11 12 13 14 15 16 17 18 19 20

*To whom correspondence should be addressed.

21

Tel (J.Y.): 86-755-26557377. Fax: 86-755-26536141. E-mail: [email protected];

22

Tel (L.Z.): 86-755-26733095. Fax: 86-755-26536141. E-mail: [email protected].

23

1

ACS Paragon Plus Environment


24

Abstract:

25

β-carotene (BC) nanoemulsions were successfully prepared by microfluidization. BC

26

micellarization was significantly affected by bile salts and pancreatin concentration.

27

Positive and linear correlation was observed between BC release and bile salts

28

concentration. Pancreatin facilitated BC’s release in simulated digestion. Compared to

29

the control (bulk oil) (4.6%), nanoemulsion delivery systems significantly improved the

30

micellarization of BC (70.9%). The amount of BC partitioned into micelles was positively

31

proportional to the length of carrier oils. Unsaturated fatty acid (USFA)-rich oils were

32

better than saturated fatty acid (SFA)-rich oils in transferring BC (p0.05). A positive and linear relationship

35

between the degree of lipolysis and the release of BC in vitro digestion was observed.

36

Bile salts showed cytotoxicity to Caco-2 cells below 20 times dilution. BC uptake by

37

Caco-2 cells was not affected by fatty acid (FA) compositions in micelles, but BC uptake

38

was proportional to its concentration in diluted micelles fraction. The results obtained

39

are beneficial to encapsulate and deliver BC or other bioactive lipophilic carotenoids in a

40

wide range of commercial products.

41 42

Keywords: β-carotene, lipids, bioaccessibility, Caco-2 cell

43

2


Page 2 of 35

Page 3 of 35

44


Introduction

45

β-carotene (BC) is one of the most highlighted naturally occurring carotenoids for

46

human health due to its high pre-vitamin A activity and strong antioxidant activity.1, 2

47

Epidemiologic research showed that BC has the ability to inhibit cancer, prevent age

48

related macular degeneration and reduce the risk of cardiovascular diseases.3, 4 BC is

49

also the precursor of ligands necessary for the activity of nuclear receptors that regulate

50

energy metabolism. Recently, some studies have shown that BC reduces weight gain

51

and may have an effect on obesity.5 Besides, as an excellent colorant, BC is widely used

52

in beverage industry.6 The color varied from yellow to orange red depending on BC

53

content.

54

However, the utilization of BC is strictly restricted due to its low solubility in water

55

and high susceptibility to isomerization, oxidation, and degradation by light, oxygen, and

56

heat. Compared to conventional emulsions, nanoemulsions are better choices to deliver

57

BC with many potential advantages (such as, better bioavailability and higher stability).7

58

Numerous studies on the physicochemical stability of BC in nanoemulsions have been

59

reported, but information that impacted BC’s bioaccessibility is lacking.8-10 Many factors

60

including particle size, carriers and emulsifiers influence the bioaccessibility of

61

encapsulated BC.11, 12 The bioavailability improved with the decrease of particle size,11, 13

62

and BC absorption was affected by dietary oils.14 Plenty of studies illustrated that dietary

63

fat could promote BC absorption,

64

carotenoids in vegetable salad with full-fat dressing were higher than that with a

65

reduced-fat salad dressing.19

15-18

compared to no oils. The bioavailability of

3



Page 4 of 35

66

In addition, BC bioavailability was also impacted by the characteristics of dietary oils.

67

In vitro, the bioavailability of BC in salad meal incorporated into micelles were raised by

68

adding long chain triglycerides (LCT) compared to medium chain triglycerides (MCT).16 In

69

humans, there is an increase in BC bioavailability when LCT were added compared to

70

MCT.20 BC bioaccessibility was relatively higher in corn oil (66%) than in MCT

71

nanoemulsion (2%).21 The small mixed micelles formed through MCT digestion may be

72

the main reason for the low BC bioaccessibility. The authors also demonstrated the

73

modulation of BC bioaccessibility by controlling oil composition and concentration in

74

nanoemulsion delivery systems.22 The saturation degrees of oils used in nanoemulsions

75

may also impact the transfer of BC. However, to date, no such study was reported.

76

A recent study illustrated that compared with oils rich in monounsaturated fatty acid

77

(MUFA) and polyunsaturated fatty acid (PUFA), dietary oils rich in saturated fatty acid

78

(SFA) leaded to a higher bioavailability of lutein and zeaxanthin.23 Nevertheless, a study

79

in humans showed that lutein and α-carotene absorption was better in MUFA rich

80

canola oil than in SFA rich butter.24 These contradictory findings highlighted the need for

81

additional investigations.

82

In this research, six dietary lipids (corn oil, canola oil, olive oil, palm oil, coconut oil,

83

and MCT) based on their distinctly different fatty acid compositions (Table 1) were

84

selected as BC carriers and six BC nanoemulsions were prepared. The composition of six

85

lipids was analyzed by saponification with ethanolic KOH solution (1.0M KOH in 90%

86

ethanol) followed by fatty acyl methylation in the presence of 20% 1,1,3,3-

87

tetramethylguanidine

(TMG)/methanol

(v/v)

4

solutions


and

detected

by

gas

Page 5 of 35


88

chromatography.25 Reboul et al.26 showed that the results obtained about carotenoids

89

uptake with in vitro models were well correlated with in vivo absorption studies. In this

90

study, both in vitro simulated gastrointestinal digestion and cellular uptake by Caco-2

91

cells model were used for screening BC bioavailability. The goal of this study was to

92

obtain a better understanding of the effect of oils on BC bioaccessibility in

93

nanoemulsions.

94 95

Materials and Methods

96

Materials

97

Corn oil, canola oil, and olive oil were purchased from a local market (Albany, CA,

98

U.S.). Neobee 1053 (medium-chain triglycerides, MCT) was kindly supplied by Stepan

99

Company (Maywood, New Jersey, U.S.). Organic coconut oil and palm oil were donated

100

by Ciranda Company (Hudson, Wisconsin U.S.). Sodium caseinate (Alanate 180) was

101

purchased from Fonterra Co-operative Group (Auckland, New Zealand). β-carotene (97%,

102

#22040), pepsin (porcine, P6887), bile extract (porcine, B8631), pancreatin (porcine

103

pancreas, P7545), and HPLC-grade solvents (methanol, ethanol, acetonitrile,

104

dichloromethane, n-hexane) were purchased from Sigma-Aldrich (St. Louis, MO U.S.)

105

and used without further purification. Dulbecco’s modified Eagle’s medium (DMEM)

106

(containing 4.5 g/L D-glucose and GlutaMAX™), penicillin and streptomycin (100×), fetal

107

bovine serum (FBS), TrypLETM Select, Hanks’ balanced salt solution (HBSS), and

108

phosphate buffer solution (PBS)(10×) were purchased from GIBCO (Grand Island, NY,

109

U.S.). The human colon carcinoma cell line (Caco-2 cells, ATCC, Manassas, VA, U.S.) were

5



110

grown in DMEM. Cells after 60-80 passages were used in the uptake study. Analytical

111

grade hydrochloric acid and sodium hydroxide, sodium chloride and calcium chloride

112

were purchased from Fisher Scientific (Fair Lawn, NJ, U.S.). Ultrapure water was used in

113

all experiments.

114

Methods

115

Preparation of β-carotene emulsions

116

Sodium caseinate (SC) was dispersed in ultrapure water and stirred for 3 h to form a 2%

117

solution. β-carotene (BC, 0.1%) was dissolved in carrier oils by stirring for 5 min at 50 °C,

118

and continued to stir for 1 h at room temperature to ensure complete solubilization

119

under nitrogen. Crude emulsions of 10 wt% of the BC vegetable oils solution in the 2%

120

SC solution at a mass ratio of 1:9 (oil phase:aqueous phase) was formed by high-speed

121

homogenization for 2 min (PT10/35, Kinematica GmbH, Switzerland). The crude

122

emulsions were then further homogenized through a high pressure microfluidizer (M-

123

110L, Microfluidics, MA, U.S.) seven times at 15000 psi (103.4 MPa) at 37 °C. After the

124

preparation, all stock samples were put in a refrigerator (2–6 °C) for subsequent uses.

125

Particle diameter analysis

126

The mean particle sizes (Dz), polydispersity indices (PDI), and Z-potential were

127

determined by dynamic light scattering (Zetasizer Nano, Malvern Instruments,

128

Worcestershire, UK).

129

samples 1:100 with pH-adjusted ultrapure water (pH 7.0). The refractive index values

130

used for the instrumental analysis of oil droplets and dispersant were 1.45 and 1.33,

131

respectively. All measurements were made in triplicate and were conducted at 25 °C.

Nanoemulsion samples were prepared by diluting the stock

6


Page 6 of 35

Page 7 of 35

132


In vitro digestion

133

A two-stage in vitro digestion method was used to simulate the conditions of human

134

stomach and intestine as described by Garrett et al..27 At simulated gastric digestion

135

phase, 7.5 mL sample was mixed with 10 mL gastric fluid (3.2 mg/mL pepsin and 0.15 M

136

NaCl) in a water jacketed beaker at 37 °C (Thermo Scientific, NH, U.S.). The pH was

137

adjusted to 2.0 with 2.5 M HCl and 0.1 M NaOH and incubated with stirring at 250 rpm

138

for 1 h. For simulated intestinal digestion, the samples were immediately adjusted to pH

139

7 with 0.5 M NaOH solution. Fifteen mL of simulated intestinal fluid containing 10 mM

140

CaCl2 with different concentrations of bile extract (0.0-20 mg/mL) and pancreatin (0.0 -

141

2.4 mg/mL) at pH 7 was added to the digestion samples to facilitate lipolysis and BC

142

micellarization. Final concentrations of bile extract and pancreatin were optimized to be

143

20mg/mL and 1mg/mL, respectively. The acidity increased immediately due to the lipase

144

hydrolysis of the emulsified triglycerides and the pH was maintained at 7 by addition of

145

0.25 M NaOH using an autotitrator (TitraLab TiM840, Radiometer, Lyon, France). The

146

amount of NaOH added over time (120 min) was recorded. The temperature was kept at

147

37 °C with a thermostatic water bath and stirred at 250 rpm. The extent of lipolysis was

148

calculated from the volume of NaOH solution added at each time point by the following

149

equation.28

150 151

Where VOLNaOH is the volume of NaOH added. And ConcNaOH is 0.25 in this case.

152

Moletriglyceride was the average molecular weight of the triglycerides of vegetable oils. The

153

average molecular weight was calculated from: 7



154 155

Where Saponification value (SV) of MCT, coconut oil, palm oil, olive oil, canola oil, and

156

corn oil are 334, 252, 195, 188, 187, and 190, respectively. MwKOH is the molecular

157

weight of KOH, 56 g/mol.

158

After in vitro digestion an aliquot of the digesta was ultracentrifuged at 28,500 rpm

159

(144000×g, 10 °C) for 60 min (Beckman L8-80M ultracentrifuge, SW 40 Ti rotor), and the

160

aqueous phase (in the middle between solid and oil) was filtered through a 0.22 μm

161

filter. The filtrate containing the micellar phase was extracted and dried under a

162

nitrogen stream, redissolved in 0.5 mL n-hexane, and quantitated by HPLC as described

163

previously. Bioaccessibility was calculated by the following formula:

164 165

Cytotoxicity of BC micelles

166

Cell viability, a commonly used indicator of in vitro cytotoxicity, was evaluated by the

167

3-(4,5-Dimethylthiazol-2-yl)-2,5-diphenyltetrazolium bromide (MTT) assay. Prior to

168

analyzing the uptake of BC micelles from in vitro digestion, the potential cytotoxicity of

169

obtained BC aqueous fraction was evaluated according to previously published

170

method.29 Caco-2 cells were incubated in DMEM containing 10% FBS, 1× nonessential

171

amino acid (NAA), and 1× penicillin and streptomycin. Caco-2 cells were seeded at a

172

density of 1.2×105 cells/well of 96-well plates and incubated (Sanyo, Osaka, Japan) at 37

173

˚C in 90% humidity and 5% CO2. After 48 h incubation, the media were discharged, and

174

BC micelles after digestion diluted with DMEM at different ratio (0-100 times) were

8


Page 8 of 35

Page 9 of 35


175

added to the wells. After 4 h incubation at 37 ˚C the nano-particles containing media

176

were replaced with 100 μL of DMEM containing MTT (10 μL, 5 mg/mL in 1× PBS, pH 7.2)

177

and incubated for 2 h at 37 ˚C. Finally, the supernatant was removed and 100 μL of

178

dimethyl sulfoxide (DMSO) added. The 96-well plates were analyzed with a Multilabel

179

microplate counter (Victor3, PerkinElmer, Waltham, MA) at 570 nm. Cell viability was

180

calculated by the percentage of absorbance relative to control (treated with DMEM only).

181

Cellular uptake

182

Caco-2 cells were incubated in DMEM supplemented 10% FBS, 1× nonessential amino

183

acid (NAA), and 1× penicillin and streptomycin at 37 ˚C under 90% humidity and with 5%

184

CO2 in an incubator (Sanyo, Osaka, Japan) according to previously described method.30

185

Caco-2 cells were seeded at a density of 120,000 cells/ 25 cm2 flask. The medium was

186

changed every other day. After five days, the cell monolayers were observed with a

187

optical microscope (Leica, IL, U.S.) to ensure that the confluence reached approximately

188

90%. Caco-2 cell monolayers were washed with DMEM three times. Following 4 h

189

incubation at 37 ˚C in a CO2 incubator, the supernatants were removed and cell

190

monolayers were washed three times with pre-cooled PBS solution to stop uptake and

191

clean the surface of cell monolayers. After that, 1.0 mL 10% ethanol PBS solution was

192

added to dissociate cell monolayers. Cell suspensions were obtained with cell scrapers.

193

All of the samples were stored at -80 °C before BC analysis in less than one week.

194

Protein content analysis

195 196

Caco-2 cell protein was determined using bicinchoninic acid (BCA) assay at 560 nm with bovine serum albumin as the standard.31

9



197

β-carotene extraction and analysis

198

BC was extracted from nanoemulsions and micelles using n-hexane and ethanol32 and

199

quantitated by HPLC as described in the section. Extraction was performed by de-

200

emulsifying 0.2 mL of sample in a 10 mL Pyrex® glass tube with screw cap by adding 1.0

201

mL ethanol, followed 1.5 mL n-hexane immediately, and the contents vortexed for 10

202

seconds. The solvent layers were allowed to separate for 1-2 minutes, and the upper

203

yellow colored supernatant was transferred to a 10 mL volumetric flask. The extraction

204

was repeated with 1.5 mL n-hexane three times until the ground layer was clear. The

205

extracts were brought up to 10 mL volume. Each sample was analyzed in triplicate.

206

25 μL of 5 μg/mL trans-beta-Apo-8’-carotenal in ethanol was added to 0.4 mL Caco-2

207

cell suspension as an internal standard. The cell suspensions were extracted three times

208

with ethanol:n-hexane (1:2, v:v). Organic fractions were combined and the extract

209

concentrated under a stream of nitrogen gas at 40 ˚C. The BC extract was dissolved in

210

0.1 mL of methanol:dichloromethane (1:1, v:v) containing 0.1 % BHT for HPLC analysis.

211

The recovery of trans-beta-Apo-8’-carotenal from Caco-2 cells exceeded 94 %.

212

High-Performance Liquid Chromatography (HPLC)

213

BC extract from nanoemulsions, micelles and Caco-2 cells was quantified using an

214

Agilent 1100 HPLC system with DAD UV-vis absorption detector (Agilent, Santa Clara, CA)

215

as previously described.10, 30 A C30 reverse-phase analytical column (YMC Carotenoid,

216

250×4.6 mm i.d., 5μm, YMC, Inc., Wilmington, NC) was used to separate the carotenoids

217

preceded by a reverse-phase C18 guard column (50×3.0 mm i.d., 5μm, YMC, Inc.,

218

Wilmington, NC) with a flow rate of 1 mL min-1 at room temperature. The injection

10


Page 10 of 35

Page 11 of 35


219

volume was 20 μL and the detection wavelength was 450 nm. The chromatography

220

conditions were as follows: Solvent A: methanol: acetonitrile: H2O (84:14:2, v/v/v),

221

solvent B: dichloromethane. The solvent gradient program was: 80A:20B to 45A:55B

222

from 0-15 min, and 45A:55B for 15-20 min, and 80A:20B from 20-25 min. The standard

223

curve of the absorption peak area versus BC concentration was plotted and fitted with a

224

linear function.

225

Statistical Analysis

226

All experiments were performed at least three times and were reported as mean ±

227

standard deviation. The data were analyzed by the analysis of variance (ANOVA) using

228

the SPSS 17.0 package (IBM, New York). Duncan’s multiple range test was used to

229

determine the significant differences of the mean values (P

Effects of Lipids on in Vitro Release and Cellular ... - ACS Publications

Recommend Documents