Solvent-Induced Crystallization Behaviors of PLLA Ultrathin Films

Oct 9, 2014 - The crystallization of poly(l-lactide acid) (PLLA) ultrathin films induced by different solvents was investigated using reflection–abs...
2 downloads 7 Views 8MB Size
Article pubs.acs.org/JPCB

Solvent-Induced Crystallization Behaviors of PLLA Ultrathin Films Investigated by RAIR Spectroscopy and AFM Measurements Ningjing Wu,* Shuguo Lang, Hong Zhang, Meichun Ding, and Jianming Zhang Key Laboratory of Rubber-Plastics, Ministry of Education/Shandong Provincial Key Laboratory of Rubber-Plastics, Qingdao University of Science & Technology, Qingdao City 266042, People’s Republic of China ABSTRACT: The crystallization of poly(L-lactide acid) (PLLA) ultrathin films induced by different solvents was investigated using reflection− absorption infrared (RAIR) spectroscopy and atomic force microscopy (AFM). Irregular PLLA dendrite lamellae grew in the flat-on orientation with dichloromethane solvent before being redissolved after longer induction times owing to the strong interaction between the PLLA segments and solvent molecules. Faster formation of PLLA spherulites was induced with acetone than with dichloromethane, and these remained unchanged with increasing induction time because of the polarity difference between the PLLA segments and acetone molecules. PLLA ultrathin films could not be induced to crystallize using chloroform because of the very strong interactions between the chloroform (CHCl3) molecules and PLLA amorphous chains, which caused the CHCl3 solvent molecules to rapidly permeate the PLLA random coils and dissolve the amorphous chains. These phenomena are attributed to solvent-specific competition between solventinduced crystallization and dissolution effects in PLLA ultrathin films, which ultimately leads to the higher degree of crystallinity obtained with acetone than with dichloromethane. form).27 Marubayashi et al.27 investigated the formation of crystalline complexes of PLLA and specific solvent molecules using wide-angle X-ray diffraction (WAXD). They concluded that PLLA forms a crystalline complex (ε-form) with specific five-membered ring compounds including cyclopentanone (CPO), 1,3-dioxolane (DOL), γ-butyrolactone (GBL), tetrahydrofuran (THF), and N,N-dimethylformamide (DMF) below room temperature and that the ε-to-α transition occurred with solvent desorption. They also investigated various kinds of crystal-to-crystal transitions relating to PLLA cocrystallized with low-molecular weight compounds (CO2 and ε-solvents) using WAXD and Fourier transform infrared spectroscopy (FTIR). These results revealed that the guest-induced transition behaviors of noncomplex PLLA crystals were strongly influenced by the order of the noncomplex crystals (α, α′, and α″) as well as the kinds of guests.28 In a previous paper, we investigated the molecular orientation and crystallization dynamics of PLLA ultrathin films at various temperatures using in situ reflection−absorption infrared (RAIR) spectroscopy. We found that the annealing temperature and thickness of the thin films has a significant effect on the crystallization kinetics and lamellar orientation of PLLA thin films.29 Because of the slow crystallization rate and low crystallinity of PLLA film, solvent induction could be an effective means of improving the degree of crystallinity in a PLLA film. Naga et

1. INTRODUCTION In recent years, polymer thin films have attracted widespread interest for applications in biomaterials, microelectronics fabrication, liquid crystal displays, photoresists for photolithography, and antireflection coatings.1,2 The confinement of polymer ultrathin films (thickness dichloromethane > chloroform. Taking the slope of the curve representing the degree of crystallinity as a function of the induction time in Figure 9 as the crystallization rate, the same ordering of the solvents is obtained, namely, acetone > dichloromethane > chloroform.

In the initial diffusion stage, the solvent molecules diffuse into and interact with the PLLA random coil chains to activate the motion of the PLLA segments. Because the interaction between chloroform molecules and PLLA amorphous chains is very strong, the chloroform molecules diffuse rapidly into the PLLA thin film, interact with PLLA random coils, and dissolve the amorphous chains, such that chloroform cannot induce the formation of crystalline PLLA. In a second induction stage, the solvent molecules promote PLLA segments to arrange into short regular helical chains and long crystal lattices. The formation of PLLA irregular dendrite crystals is induced by dichloromethane, where the dendrite lamellae grow preferentially in the flat-on orientation. Acetone provokes the PLLA segments to form spherulites in less than 10 min. This rapid induction of crystallization by the solvent leads to the distortion and contortion of the PLLA lamella, such that they present different orientations in the PLLA spherulites. With increasing induction time, the solvent molecules continue to diffuse into the PLLA crystal lattice and interact with PLLA segments. Because of the strong interaction between the PLLA segments and dichloromethane molecules, the PLLA dendrite crystals redissolve in dichloromethane. However, the PLLA spherulites remain unchanged because of the weak interaction between the acetone molecules and PLLA segments. These phenomena are attributed to solvent-specific competition between solventinduced crystallization and dissolution effects in PLLA ultrathin films.



AUTHOR INFORMATION

Corresponding Author

*E-mail: [email protected]; ningjing_wu@qust. edu.cn. Notes

The authors declare no competing financial interest.

■ ■

ACKNOWLEDGMENTS This work was supported by the National Natural Science Foundation of China (21104038). Figure 9. Relative degree of crystallinity changes of PLLA ultrathin films induced by different solvents with induction time.

REFERENCES

(1) Frank, C. W.; Rao, V.; Despotopoulou, M. M. Structure in Thin and Ultrathin Spin-Cast Polymer Films. Science 1996, 273, 912−915. (2) Walheim, S.; Schäffer, E.; Mlynek, J.; Steiner, U. NanophaseSeparated Polymer Films as High-Performance Antireflection Coatings. Science 1999, 283, 520−522. (3) Kim, J. H.; Jang, J. S.; Zin, W. C. Thickness Dependence of the Melting Temperature of Thin Polymer Films. Macromol. Rapid Commun. 2001, 22, 386−389. (4) Zhang, Y.; Zhang, J. M.; Lu, Y. L.; Duan, Y. X.; Yan, S. K.; Shen, D. Y. Glass Transition Temperature Determination of Poly (Ethylene Terephthalate) Thin Films Using Reflection-Absorption FTIR. Macromolecules 2004, 37, 2532−2537. (5) Liang, T.; Makita, Y.; Kimura, S. Effect of Film Thickness on the Electrical Properties of Polyimide Thin Films. Polymer 2001, 42, 4867−4872. (6) Jayarajah, C. N.; Yekta, A.; Manners, I.; Winnik, M. A. Oxygen Diffusion and Permeability in Alkylaminothionylphosphazene Films Intended for Phosphorescence Barometry Applications. Macromolecules 2000, 33, 5693−5701. (7) Pfromm, P. H.; Koros, W. J. Accelerated Physical Ageing of Thin Glassy Polymer Films: Evidence from Gas Transport Measurements. Polymer 1995, 36, 2379−2387. (8) Tan, N. C.; Wu, W. L.; Wallace, W. E.; Davis, G. T. Interface Effects on Moisture Absorption in Ultrathin Polyimide Films. J. Polym. Sci., Part B: Polym. Phys. 1998, 36, 155−162.

4. CONCLUSIONS On the basis of the results described above regarding the changes in the RAIR spectra of PLLA ultrathin films crystallized using different solvents, the schematic of the aggregation and structural evolution of PLLA ultrathin film shown in Figure 9 is proposed (see Scheme 2). In particular, the results suggest that the solvent-induced crystallization process of PLLA ultrathin films is divided into several stages. Scheme 2. Aggregation Structural Evolution Process of PLLA Thin Films Induced by Different Solvents

12658

dx.doi.org/10.1021/jp506840e | J. Phys. Chem. B 2014, 118, 12652−12659

The Journal of Physical Chemistry B

Article

(29) Wu, N. J.; Ding, M. C.; Li, C. W.; Yuan, Y.; Zhang, J. M. Lamellar Orientation and Crystallization Dynamics of Poly(L-Lactic Acid) Thin Films Investigated by In-Situ Reflection Absorption Infrared Spectroscopy. J. Phys. Chem. B 2011, 115, 11548−11553. (30) Zhang, J. M.; Duan, Y. X.; Sato, H.; Tsuji, H.; Noda, I.; Yan, S. K.; Ozaki, Y. Crystal Modification and Thermal Behavior of Poly (Llactic acid) Revealed by Infrared Spectroscopy. Macromolecules 2005, 38, 8012−8021. (31) Zhang, J. M.; Tashiro, K.; Tsuji, H.; Domb, A. J. Disorder-toOrder Phase Transition and Multiple Melting Behavior of Poly (Llactide) Investigated by Simultaneous Measurements of WAXD and DSC. Macromolecules 2008, 41, 1352−1357. (32) Castillo, R. V.; Muller, A. J.; Raquez, J. M.; Dubois, P. Crystallization Kinetics and Morphology of Biodegradable Double Crystalline PLLA-b-PCL Diblock Copolymers. Macromolecules 2010, 43, 4149−4160. (33) Zhang, J. M.; Duan, Y. X.; Domb, A. J.; Ozaki, Y. PLLA Mesophase and Its Phase Transition Behavior in the PLLA−PEG− PLLA Copolymer As Revealed by Infrared Spectroscopy. Macromolecules 2010, 43, 4240−4246. (34) Naga, N.; Yoshida, Y.; Inui, M.; Noguchi, K.; Murase, S. Crystallization of Amorphous Poly(lactic acid) Induced by Organic Solvents. J. Appl. Polym. Sci. 2011, 119, 2058−2064. (35) Tashiro, K.; Ueno, Y.; Yoshioka, A.; Kobayashi, M. Molecular Mechanism of Solvent-induced Crystallization of Syndiotactic Polystyrene Glass. 1. Time-Resolved Measurements of Infrared/ Raman Spectra and X-ray Diffraction. Macromolecules 2001, 34, 310− 315. (36) Yoshioka, A.; Tashiro, K. Solvent Effect on the Glass Transition Temperature of Syndiotactic Polystyrene Viewed from Time-Resolved Measurements of Infrared Spectra at the Various Temperatures and Its Simulation by Molecular Dynamics Calculation. Macromolecules 2004, 37, 467−472. (37) Hashida, T.; Tashiro, K.; Aoshima, S.; Inaki, Y. Structural Investigation on Water-induced Phase Transitions of Poly (ethylene imine). 1. Time-Resolved Infrared Spectral Measurements in the Hydration Process. Macromolecules 2002, 35, 4330−4336. (38) Yang, P.; Han, Y. C. Crystal Growth Transition from Flat-on to Edge-on Induced by Solvent Evaporation in Ultrathin Films of Polystyrene-b-Poly (ethylene oxide). Langmuir 2009, 25, 9960−9968. (39) Wu, P. X.; Zhang, L. C. Polymer Blends Modification; Light Industry Press: Beijing, China, 2004; p 37.

(9) Jukes, P. C.; Das, A.; Durell, M.; Trolley, D.; Higgins, A. M.; Geoghegan, M. Kinetics of Surface Crystallization in Thin Films of Poly (ethylene terephthalate). Macromolecules 2005, 38, 2315−2320. (10) Kawamoto, N.; Mori, H.; Nitta, K. H.; Sasaki, S.; Yui, N.; Terano, M. Microstructural Characterization of Polypropene Surfaces Using Grazing Incidence X-ray Diffraction. Macromol. Chem. Phys. 1998, 199, 261−266. (11) Yang, H.; Kim, S. H.; Yang, L.; Yang, S. Y.; Park, C. E. Pentacene Nanostructures on Surface-Hydrophobicity-Controlled Polymer/SiO2 Bilayer Gate-Dielectrics. Adv. Mater. 2007, 19, 2868− 2872. (12) Sun, X. L.; Chen, Z.; Wang, F.; Yan, S. K.; Takahashi, I. Infulence of Poly(vinylphenol) Sublayer on the Crystallization Behavior of Poly(3-hydroxybutyrate) Thin Films. Macromolecules 2013, 46, 1573−1581. (13) Sun, X. L.; Tokuda, A.; Oji, Y.; Nakatani, T.; Tsuji, H.; Ozaki, Y.; Yan, S. K.; Takahashi, I. Effects of Molar Mass of Poly(L-lactide Acid) on the Crystallization of Poly[(R)-3-hydroxybutyrate] in Their Ultrathin Blend Films. Macromolecules 2013, 45, 2485−2493. (14) Schonherr, H.; Frank, C. W. Ultrathin Films of Poly (ethylene oxides) on Oxidized Silicon. 2. In Situ Study of Crystallization and Melting by Hot Stage AFM. Macromolecules 2003, 36, 1199−1208. (15) Wang, Y.; Chan, C. M.; Ng, K. M. What Controls the Lamellar Orientation at the Surface of Polymer Films during Crystallization? Macromolecules 2008, 41, 2548−2553. (16) Krikorian, V.; Pochan, D. J. Crystallization Behavior of Poly (Llactic acid) Nanocomposites: Nucleation and Growth Probed by Infrared Spectroscopy. Macromolecules 2005, 38, 6520−6527. (17) Rahman, N.; Kawai, T.; Matsuba, G.; Nishida, K.; Kanaya, T.; Watanabe, H.; Okamoto, H.; Kato, M.; Usuki, A.; Matsuda, M.; Nakajima, K.; Honma, N. Effect of Polylactide Stereocomplex on the Crystallization Behavior of Poly (L-lactic Acid). Macromolecules 2009, 42, 4739−4745. (18) Cartier, L.; Okihara, T.; Ikada, Y.; Tsuji, H.; Puiggalí, J.; Lotz, B. Epitaxial Crystallization and Crystalline Polymorphism of Polylactides. Polymer 2000, 41, 8909−8919. (19) Pan, P. J.; Inoue, Y. Polymorphism and Isomorphism in Biodegradable Polyesters. Prog. Polym. Sci. 2009, 34, 605−640. (20) Aleman, C.; Lotz, B.; Puiggali, J. Crystal Structure of the α-Form of Poly (L-lactide). Macromolecules 2001, 34, 4795−4801. (21) Wasanasuk, K.; Tashiro, K.; Hanesaka, M.; Ohhara, T.; Kurihara, K.; Kuroki, R.; Tamada, T.; Ozeki, T.; Kanamoto, T. Crystal Structure Analysis of Poly(L-lactic Acid) α Form On the basis of the 2-Dimensional Wide-Angle Synchrotron X-ray and Neutron Diffraction Measurements. Macromolecules 2011, 44, 6441−6452. (22) Wasanasuk, K.; Tashiro, K. Crystal Structure and Disorder in Poly(L-lactic Acid) δ Form (α′ Form) and the Phase Transition Mechanism to the Ordered α Form. Polymer 2011, 52, 6097−6109. (23) Wasanasuk, K.; Tashiro, K. Structural Regularization in the Crystallization Process from the Glass or Melt of Poly(L-lactic Acid) Viewed from the Temperature−Dependent and Time-Resolved Measurements of FT-IR and Wide-Angle/Small-Angle X-ray Scatterings. Macromolecules 2011, 44, 9650−9660. (24) Marubayashi, H.; Akaishi, S.; Akasaka, S.; Asai, S.; Sumita, M. Crystalline Structure and Morphology of Poly(L-lactide) Formed under High Pressure CO2. Macromolecules 2008, 41, 9192−9203. (25) Sawai, D.; Takahashi, K.; Sasashige, A.; Kanamoto, T.; Hyon, S. H. Preparation of Orientated β-Form Poly(L-lactic Acid) by Solid Coextrusion: Effect of Extrusion Variables. Macromolecules 2003, 36, 3601−3605. (26) Cartier, L.; Okihara, T.; Ikada, Y.; Tsuji, H.; Puiggali, J.; Lotz, B. Epitaxial Crystallization and Crystalline Polymorphism of Polylactides. Polymer 2000, 41, 8909−8919. (27) Marubayashi, H.; Asai, S.; Sumita, M. Complex Crystal Formation of Poly(L-lactide) with Solvent Molecules. Macromolecules 2012, 45, 1384−1397. (28) Marubayashi, H.; Asai, S.; Sumita, M. Guest-Induced Crystal-toCrystal Transitions of Poly(L-lactide) Complexes. J. Phys. Chem. B 2013, 117, 385−397. 12659

dx.doi.org/10.1021/jp506840e | J. Phys. Chem. B 2014, 118, 12652−12659