The Preparation and Properties of Trifluoroiodoethene1 - Journal of

Support. Get Help · For Advertisers · Institutional Sales; Live Chat. Partners. Atypon · CHORUS · COPE · COUNTER · CrossRef · CrossCheck Depositor · O...
0 downloads 0 Views 526KB Size
Jan. 5 , 19%

PREPARATION AND PROPERTIES OF TRIFLUOROIODOETHENE

revision of Rossini’s “best” combustion values15 in terms of the presently accepted atomic weights and Jessup’s corrected result16 for the heat of combustion of the benzoic acid standard. The value for n-butyraldehyde was then deduced from this butyl alcohol datum on the assumption that Kistiakowsky’s result17 for the heat of dehydrogenation of ethyl alcohol to acetaldehyde can also be applied to the corresponding four-carbon compounds. In this latter case the heats of vaporization of the n-butyl alcohol and aldehyde were I ~ 7.90 kcal.,18respectively. taken as 11.80k ~ a 1 . and Unfortunately, complete thermal data were not available for an analogous calculation in the case of n-heptaldehyde. In general, the free energies so derived are probably reliable to within 0.08 kcal. per carbon atom, (15) F. D. Rossini, J . Research N a t l . Bur. Sfandards, 13, i s 9 (1934). (16) R . S. Jessup, i b i d . , 36, 421 (1946). (17) M, A. Dolliver, T. L. Gresham, G. B. Kistiakowsky, E. A. Smith a n d W. E. Vaughan, THISJOURNAL, 60, 440 (1938). (18) C. B. Longsworth, a n unpublished research in t h e Stanford Laboratory.

[CONTRIBUTIONFROM

THE

59

although in the case of n-butyraldehyde the error may possibly be twice this latter figure. While we shall not now resort to a detailed discussion of these results, it is noteworthy that the average change in molal free energy per CH2 increment is here 1.43 kcal. in going from n-butyl alcohol to liquid cetyl alcohol as against a value of 1.21 kcal. previously found in the series of liquid normal paraffins9 It is also interesting to observe the difference of 7.33 kcal. in the molal free energies of n-butyraldehyde and methyl ethyl ketone, which is certainly real although one might intuitively expect approximately equal free energies for such isomers. Likewise, a comparison of these values for the several alcohols with those for the parent hydrocarbonsll demonstrates that the introduction of the hydroxyl group produces an average lowering of 35 kcal. in the molal free energy for the production of a primary alcohol as against about 39 kcal. in the formation of the secondary alcohol, cyclopentanol. STANFORD, CALIFORNIA

DEPARTMENT OF CHEMISTRY, UNIVERSITY

OF

COLORADO]

The Preparation and Properties of Trifluoroiodoethene’ BY J. D. PARK,R. J. SEFFL~ AND J. R. LACHER RECEIVED JUNE 30, 1955 The preparation of perfluorovinyl iodide and its reaction with ethylene, vinyl fluoride, vinylidene fluoride, trifluoroethane l,l-difluoro-2,2-dichloroethene and l,l-diAuoro-2-chloroetheneis described and the structures of the resultant butenes are discussed. I t has been found that the attacking peduorovinyl free radical attaches itself to the variously substituted CFH ethylenic carbon atoms in the order CHz > CHCl > CFZ > The preparation of some fluorinated butadienes is described.

The new peduorovinyl iodide has been synthesized from commercially available starting material. The first step in the synthesis involves the addition of hydrogen bromide to 1,1,2-trifluoro-2chloroethene,3 dehalogenation to trifluoroethene followed by reaction with iodine monochloride to give 1,1,2-trifluoro-1-chloro-2-iodoethane (I). This result is in accord with the observation by Haszeldine4 that the negative substituent (in this case C1-) becomes attached to the CF2 group in the molecule. CF2=CFI (11) is prepared from I by treatment in a suspension of powdered potassium hydroxide in mineral oil. This particular medium was used rather than the traditional alcoholic potassium hydroxide since I1 reacts readily with alcoholic alkali to form ethers. The ultraviolet absorption spectrum of I1 shows a distinct band with the maximum a t 258 mp. This band is characteristic of aliphatic fluorinated iodides and Haszeldines re(1) Abstracted f r o m a thesis by R . J. Seffl, submitted t o the Gradua t e School of t h e University of Colorado in partial fulfillment of t h e requirements for t h e degree Doctor of Philosophy, June, 1954. Presented before t h e Fluorine Subdivision of t h e Division of Industrial and Engineering Chemistry, 126th Meeting of t h e American Chemical Society, N. Y . C., Sept. 12-17, 1954. (2) E. I. d u P o n t Predoctoral Fellow in Chemistry, 1953-1931. (3) J. D . Park, W. R. Lycan and J. R.Lacher, THISJOURNAL, 73, 711 (1951). (4) R. N. Haszeldine, J. Chcm. Soc., 4423 (1952). ( 5 ) R. N. Haszeldine, i b i d . , 1764, 3761 (1953).

ports that the exact position of the band is dependent on the nature of the molecule. Free Radical Reactions of Pefluorovinyl IodideThe Preparation of Some Fluorinated Butadienes Perfluorovinyl iodide will react with other olefins such as ethylene, vinyl fluoride, vinylidene fluoride and trifluoroethene to form a linear 1:l addition product in the presence of ultraviolet light as CF*=CFI

+ CXz=CHX

---f

CFz=CFCHXCXzI

where X = H or F. In accordance with a general mechanism as proposed by Haszeldine,6 we propose the following mechanism for the reaction

+

Initiation: CFz=CFI +CFz=CF. 1. (1) Propagation: CFz=CF. CXQ=CHX + CFzCFCHXCXz. (2) Chain transfer: CF?=CFCHXCXz. CFz=CFI ----f CFzCFCHXCXnI CFz=CF. (3)

+

+

+

It is to be noted that in step (1) the formation of a peduorovinyl free radical is suggested. The existence of such a free radical has little precedent in the literature. With regard to other vinyl free radicals it is noted that Tickner and c o - w o r k e r ~ ~ ~ ~ b (6) R . N. Haszeldine, i b i d . , 2856 (1949); 167, 39 (1951); Nature, 165, 152 (1950); J . Chem. SOC., 3037 (1951). (7) (a) A. W. Tickner, J. W. Hodgins and D . J. Leroy, Can. J. Rcscauch, B26, 619 (1948); (b) A. W. Tickner a n d D. J. Leroy, J . Cbcm. Phrs., 19, 1247 (1951).

60

J. D. PARK,R. J. SEFFLAND J. R. LACHER

Vol. 78

Experimentall 4 obtained the free radical CHz=CH. from vinyl bromide and vinyl iodide and recently Lindsey and CF2Br-CFHC1 and CFz=CFH were prepared by procedI n g r a h a d have postulated the intermediate forma- ures previously reported . 3 Addition of Iodine Monochloride to Trifluoroethene.tion of a cyclohexenyl free radical. The addition of iodine monochloride t o trifluoroethene was I n step ( 2 ) of the reaction mechanism the attack carried out in a high pressure autoclave under autogenous by the free radical is upon the C X H group rather pressure. The reaction products were washed with 5% than the CX2 group of the ethene. Haszeldineg sodium bisulfite t o remove any iodine or iodine monochloin a study of the direction of addition of trifluoro- ride, then with water, and dried over calcium sulfate. The product was distilled in a Vigreux column to give 170 g. of iodomethane to unsymmetrical olefins has ob- product boiling between 76.5 and 77.5' a t 630 mm. Conserved that the attacking free radical will go first version to 1,1,2-trifluoro-l-chloro-2-iodoethane( I ) was to a CH2 group, then to a CFH and finally to a CF2 found to be 72%; molecular weight determinations by the group. This order of addition has also been sub- Regnault method (calcd. for C2F3HC11: mol. wt. 244, 238) and molar refraction values (calcd., 29.10: stantiated by Tarrant.'O Accordingly, the addi- found, found, 29.10). tion products with vinyl fluoride, vinylidene fluoAnal. Calcd. for CyF3HClI; C, 9.8; F , 23.3. Found: ride and trifluoroethene should have the following C, 9.9; F , 23.1. structures: CF2=CFCH2CHFI (111), CF2=CFThe correctness of the structure assigned to I was further CHzCFzI (IV) and CF2=CFCFHCF21 (V). Fur- established by its conversion to perfluorovinyl iodide. This ther evidence of the structures as listed above is compound has physical properties entirely different from chIorotrifluoroethene which would have resulted had the given by the fact that each of the above butenes iodine monochloi ide adduct been the 1,1,2-trifluoro-2-chlororeacted with potassium hydroxide to yield the re- 1-iodoethane isomer. Perfluorovinyl Iodide (CF*=CFI) (II).-The dehydrospective butadiene. If the structures for IV and V were other than those written above, the de- chlorination of I was carried out in a 200-ml. three-neck equipped with stirrer, dropping funnel and reflux conhydroiodination reaction could not have taken flask denser. The effluent gases from the reflux condenser were place. collected in a solid carbon dioxide-acetone cooled trap. When I1 was subjected to ultraviolet irradiation, About 48 g. (0.197 mole) of I was added dropwise to a susa dimeric product containing iodine was formed. pension of 28 g. (0.5 mole) of powdered potassium hydroside in 45 ml. of mineral oil under vigorous agitation. The The presence of unsaturation in the product elimi- mineral oil was maintained a t 95' and the condenser heated nated the possibility of the cyclic dimer, namely, to 35" to permit removal of the olefin from the reaction 1,a-diiodo-1,2,3,3,4,4-hexafluorocyclobutane, The mixture. Stirring and heating were continued for four hours only other possible products from the reaction are after the addition of I was completed t o ensure complete removal of the olefin. The products obtained were trans4,4-diiodoperfluorobutene-1(VI) and 3,4-diiodo- ferred t o a micro-distillation apparatus and distilled. The perfluorobutene-1 (VII). Since the product ob- product 11, distilled a t 27.5 to 28.5' a t 627 mm. and the tained did not react with zinc to form perfluorobuta- conversion, based on starting materials was 76%. Physidiene, the dimer must have been the gem-diiodide cal properties and molar refraction values are given in Table I . The infrared spectrum displayed the presence of a C=C (VI). This result is in agreement with work by bond at 5.66 p. Haszeldine," hliller12and HenneI3who showed that Anal. Calcd. for CyF31: C, 11.6; F , 27.4; mol. wt., 208. the attacking trifluoromethyl free radical will be- Found: C, 11.7; F , 27.2; mol. wt., 207. come attached to a CF2 group in preference to a Preparation of Halogenated Butenes by the Reaction of Variously Substituted Ethylenes with 11.-The free radical CFCl group. reactions were carried out in a 5-1. Pyrex flask The reaction of perfluorovinyl iodide with 1,l- addition which was sealed off a t the neck and fitted with a stopcock difluoro-2,2-dichloroethylene and 1,l-difluoro-2- t o permit the introduction and removal of the reactants and chloroethylene yielded 1,1,2,3,3-pentafluoro-4,4-diproducts. The ultraviolet light source was a Hanovia EH4 chloro-4-iodobutene-1 (17111) and 1,1,2,4,4-penta- mercury arc tube and the reaction time in all cases was for a period of seven days. fluoro-3-chloro-4-iodo-butene-1 (IX). In a typical reaction 21 g. (0.10 mole) of I1 and 4.2 g. In summarizing, it has been found that an at- (0.15 mole) of ethylene were charged t o the reactor and tacking perfluorovinyl free radical attaches itself irradiated for seven days. At the end of this period a liquid to the variously substituted ethylenic carbon at- product highly colored with iodine was obtained. This oms in the following order: CH2 > CFH,CHCI > crude product, 23 g., was distilled ina Metroware column. The product, 16.2 g. (67% of theory) distilled a t 112" a t CFz > CF1,CCL. 623 mm. and gave a positive test for unsaturation with The utilization of the previously discussed free potassium permanganate solution. radical addition type of reaction has resulted in the A n d . Calcd. for CaF3HJ: C, 20.3; F , 24.5; mol. wt., preparation of the following butadienes: 1,1,2-tri- 236. Found: C, 20.3; F , 24.7; mol. wt. (Regnault fluorobutadiene, 1,1,2,4tetrafluorobutadiene,l , l , - method), 229. The following reactions were carried out in an analogous 2,4,4-pentafluorobutadiene and hexafluorobutadimanner ulth the converslons as noted ene. (8) R. V. Lindsey and J. X, Ingraham, THISJ O U R N A L 75, 5613 (1953). (9) R. N. Hasaeldine, J . Chern. SOC.,2604 (1952); 1199, 1592, 3565 (1953); R. N. Haszeldine, Abstracts of 112th Meeting of the American Chemical Society, Chicago, Illinois (September 19531, p. 35M. (10) P. Tarrant and A . 1RI. Lovelace, THIS J O U R N A L , 77, 768 (1955). (11) R. 9. Haszeldine and B 11. Steele, C h e m i s t r y arid I ? Z d U s t i ' Y , 684 ( 19311. (12) W. T. hfiller, Jr., and J. &I. Howald, Abstracts of 122nd Rleeting of the American Chemical Snciety. Atlantic City, N . 1. (Sei)ternber, 195?), p. 1 2 K . (13) A 1,. Henne and D. \V. Krau.;, THISJ O U R N A L 76, 117.1 (1034)

CFz=CFI

+ CHz=CFH

CFZ=CFI

4- CHz=CF2 +

CFz=CFI

4- CFz=CFH

---f

CFz=CFCHZCFHI CFz=CFCHXFzI --f

CFZ=CFCFHCF>I 2CFz=CFI

+ CF?=CFCF?CFI?

CF2=CFI 4 CF2=CHC1 ~

- .

~~

+ CFl=CFCHClCF21

(14) 411 boiling points are uncorrected

PREPARATION AND PROPERTIES OF TRIFLUOROIODOETHENE

Jan. 6, 1956

TABLE I PHYSICAL PROPERTIES OF COMPOUNDS PREPARED Compound

CFzClCFHI CF*=CFI

Mol. wt.

'c.

244 208

77 28

236 254 272 290 416 108 126 144 162 341 306 254 CFz=CFI

+ CFz=CC12

A RF

B.P. Mm.

nZoD

630 627

1.4320 1.4143 (0°) 1.4554 1.4370 1.4118 1.4006 1.4794

112 107 92 83 146 0.5

623 633 633 631 622 585

10.2

630 627 624 624 630

3 160 127 122

dl01

M&b..

M&slcd.

2.181 29.10 28.89 2.284 22.70 23.50

obsd.

M&bed.

1.10 0.74

238 207

1.01 0.95 1.06 1.18 1.26

229

61

Analyses, % Carbon Fluorine Calcd. Found Calcd. Found

9.8

9 . 9 2 3 . 3 23.1

11.6 11.7 27.4 27.2

(0°) 1.957 2.052 2.060 2.103 2.522

32.74 32.42 32.83 33.47 46.80

32.90 32.73 32.66 32.59 45.39

..

.. .. .. 109 130 146 161

1.4635 2.232 42.11 42.74 0 . 9 8 1.4391 2.177 37.52 37.03 0 . 9 3 1.4189 1.839 34.88 34.91 1.02

--j

20.3 18.9 17.6 16.5 11.5 44.4 38.1 33.3

20.4 18.8 17.4 16.3 11.2 44.2 38.0 33.0

24.5 29.9 34.9 39.3 27.4 52.8 60.3 65.9

24.7 29.8 35.1 39.1 27.2 52.6 60.6 65.7

1 4 . 1 14.4 2 7 . 8 27.7 15.7 15.5 31.0 31.0 18.9 19.0 22.4 22.2

cc. of dioxane. The reaction temperature was 95" and heating was continued for 4 hours. At the end of this period no liquid had collected in the cold trap (expected b.p. of CF,=CF-CCl=CFt about 50-60 ") and analysis of the zinc halide showed no chloride to be present. On the basis of this lack of reactivity with zinc the butene is assigned the structure VI11 rather than the isomer 1,1,2,4,4pentafluoro-3,3-dichloro-4-iodobutene-l. Thermal Dimerization of CF9=CFI.-About 34 g. of CFz=CFI was placed in a Carius tube 2.5 X 30 cm. and sealed. This tube was then heated a t 170-180' for 24 hours. The following products were obtained: 9.7 g. of unchanged CF*=CFI, 7 g. of a low boiling liquid and a considerable amount of solid iodine. The low boiling liquid was identi; fied as CF2-CF2-CF=CF with a boiling point of -4

CF2=CFCF2CClzI (VIII) 5% The above butenes all reacted to give a positive test for unsaturation with dilute potassium permanganate solution. The physical properties and analyses of the various butenes are listed in Table I. Preparation of CF2=CF-CH=CH2 .-In a typical run 6.6 g. of 1,1,2-trifluoro-4-iodobutene-l(111) was added dropwise to a suspension of powdered potassium hydroxidz in 10 cc. of mineral oil. The reaction was carried out a t 95 and the gaseous product was collected in a carbon dioxideacetone cooled receiver. The condensed gas (1.4 g. or 52% of theory) had an experimental molecular weight of 109 (calcd. for C4F3H3: mol. wt., 108) and a boiling point of 0.5" a t 585 mm. pressure, and its infrared spectrogram compared very favorably with the authentic spectrogram for the dieneIs prepared from CFzClCFCl-CH2-CH2I. Preparation of CF*=CH-CH=CFH .-This diene was prepared in a similar manner noted above from CF*=CFCHzCHFI. The product had an experimental molecular weight of 130 (calcd. for C4H2F4: mol. wt., 126) and its infrared spectrogram displayed a doublet in the 5.70 p region which is characteristic of a conjugated diene. Attempts to determine the boiling point of the diene were unsuccessful due to rapid polymerization which took place. (The analysis was carried out on a gas sample which had been distilled three times (pot to pot) in a vacuum system.) Preparation of CFz=CF-CH=CF2 .-This diene was prepared in a similar manner from CF?=CF-CH?CFzI. I t had a boiling point of 10-11" a t 630 mm. pressure and an experimentally determined molecular weight of 145 (calcd. for CdFsH: mol. wt., 144). Similar results (somewhat poorer yields) were obtained by the dehalogenation of CFZ=CF--CHClCF21 with zinc a t 95'. The infrared spectrum displayed a doublet characteristic of dienes a t 5.60-5.80 ,u. Preparation of CF2=CF-CF=CFz .-The dehydroiodination of CFz=CF-CFH-CFJ yielded perfluorobutadiene (2 g. 67% of theory) which was condensed in a Dry Iceacetone cooled trap. It had an experimentally determined molecular weight of 161 (calcd. for C4F6: mol. wt. 162) and a reflux boiling point of 2.5-3" a t 630 mm. The infrared spectrogram of this diene was identical with the spectroobtained from gram of the authentic CF*=CF-CF=CF* M. W. Kellogg Co. of Jersey City, Xew Jersey. The physical properties of the dienes and the experimental molecular weights are given in Table I along with the analytical data. Reactions of Butenes with Zinc. (a) 4,4-Diiodoperfluorobutene-1 (VI).-1.0 g. of this compound did not react with 2 g. of zinc in 2 cc. of absolute ethanol. On the basis of this result the butene was assigned the structure \'I rather than VII. (b) 4,4-Dichloro-4-iodoperfluorobutene-l(VU).-3.0 g. of this compound was treated with 1 g. of zinc dust in 10

and a freezing point of - 59.3 to - 60 .so. Grignard Formation.-About 3.0 g. of Mg was placed in a 300-ml. three-neck flask equipped with stirrer, reflux condenser and dropping funnel. A Dry Ice-acetone cooled trap was attached to the condenser. A stream of oxygenfree nitrogen was passed through the system and the pot flamed to remove any traces of moisture. About 100 ml. of diethyl ether was added to the Mg and 27 g. of CF?= CFI was placed in the dropping funnel. A crystal of iodine was added to aid in initiating the reaction and a small amount of CFz=CFI was added to the Mg and ether. The stirred reaction mixture was walmed to reflux and the Grignard formation began in a short while. The reaction mixture was cooled to 0 " and the balance of the CF2=CFI added slowly. After complete consumption of the Mg the reaction mixture was hydrolyzed by the addition of 25 cc. of 6 N hydrochloric acid. The hydrolysis of the Grignard reagent resulted in a vigorous reaction and 2.5 g. (22% of theory based on conversion to CFz=CFH) of liquid was condensed in the Dry Ice trap. This liquid was subjected to a molecular weight determination and proved to be CFz=CFH (calcd. for C2F3H: mol. wt., 82; found, 82). The temperature of the reaction mixture was raised to 29" and an additional amount (about 2 g.) of CF2=CFH was obtained. Attempts to treat CF*=CFI with S a c s , CH3COOK and CH3COOAgin the hope of replacing the iodine atom with the respective anions have been unsuccessful. Preparation of CH~CH~OCFZCFHI .-Reaction of CF2C1CFHI and ethanol yielded the ether which distilled a t 121.5123.5" with slight decomposition, or a t 36" a t 17 mm. pressure. The identity of the ether CH~CHZOCF~CFHI was established by molar refraction values (calcd., 34.90; obsd., 34.88) ~ * O D 1.4189, d2p0 1.8387 and by analysis. Hydrolysis of CH3CH20CCF2 .CFHI-CH3CH20CF2CFHI H2S04 + CH3CHqOCOCFHI HF.-The hydrolysis was carried out by adding 90% H2SOI to 4.5 g. of the ether according to the method of Tarrant and Young.16 The acid CFHICOOH which was isolated was subjected to repeated recrystallization until a consistent melting point of 78.5-

(15) D. A. Rausch, Ph.D. Thesis, University of Colorado, 1953.

(1G) J. A. Young and P. Tarrant, THIS JOURNAL,72, 1860 (1950)

+

+

62

I D. The principal refractive indices are ZX = 1.95; nz = 1.96; n3 = 1.98. The infrared spectrum of an aqueous solution of HAu( C S ) ? has a strong absorption peak at 2147 c m . 3 , as does aqueous KAu(CN)z. A sample of solid HAu(CS)*, dried on polythene film, showed absorption bands a t 2146 and 399 cm.?. Neither the bending frequencies nor a hydrogen stretching frequency for solid HAu(CK):! were observed a t path lengths up to 0.5 mm. Thicker samples were too opaque to infrared radiation t o obtain their spectra. Solid KAu(CS)? shows absorption peaks a t 2141 and 427 cm.? (see reference 5). These peaks correspond to the asymmetric C - S stretching and asymmetric C-Au-C stretching vibrations, respectively. This indicates that probably the Au-C force constant is lower in solid HAu(CiY)2 than in solid KAu(CS)?. I n solid KAu(CX)s the peak a t 2141 cm.-' has a much higher extinction coefficient than the analogous peak of solid HAu(CX)?a t 2146 cm.-I. This indicates that although HAu(CN)? is highly ionized to H and Au(CS)?in aqueous solution, in the solid it is probably essentially un-ionized, thus greatly decreasing the extinction coefficient. A sample of HAu(CiY)p gave a powder X-ray diffraction pattern in which no lines characteristic of KAu(CN)?,or of AuC?; were recognized (see Table I). After 20 minutes heating a t 120" in the open capillary, the residue gave an X-ray diffraction pattern characteristic of A u C S and no other recognized lines. +

TABLE I PARTIAL PO\\-DERX-RAY DIFFRACTIOS PATTERN OF HAu( CS)z 11

I!lib

i1

(A,)"

I/lib

8.67 100 2.286 5 4.76